Ac Delco 16229684 Ecu Vortec

(1)

VORTEC Wiring Harness

INSTRUCTIONS & SUPPLEMENT

AL

INFORMA

TION

4.3 / 5.0 / 5.7 / 7.4

Street

&

P

erformance

#1

Hot

Rod

Lane

~

Mena,

AR

71953

Phone

479-394-5711

~

Fax

479-394-7113

email

(2)

1. Fuse Block.

2. A.L.D.L

2. A.L.D.LConnector (diagConnector (diagnostic link for plugging in scanner).nostic link for plugging in scanner).

3. Fuel Pump R

3. Fuel Pump Relayelay. (NOTE: . (NOTE: ACACDELCO EPDELCO EP381 Fuel Pump is need381 Fuel Pump is needed to supply 65 Ped to supply 65 P.S.I fuel pressu.S.I fuel pressure.)re.)

4. Color Coded PCM (computer) Connectors (4) Red, Blue, Black, and Gray.

5. Tan wire goes to the check engine light. Must supply a 12 volt hot wire to the bulb, the tan wire is the ground to

complete the circuit.

6. Red wire should have 12VDC in crank and run.

7. White wire is optional TACH signal wire - Ground Side.

8. Black wire g

8. Black wire ground to round to back of bloback of block or head. ck or head. BEBESURE to SURE to clean contclean contact point.act point. Ground Ground battery to enbattery to engine or gine or

transmission, engine to body

transmission, engine to body, and engine to frame., and engine to frame.

9. Three prong plug with a purple water type seal goes to cam sensor

10. Three prong plug with light green seal with orange, brown and white wires, go to three prong oil pressure switch

and the white wire that runs from this plug, is used with GM compatible gauges, But if you use VDO Stewart Warner,

ect, you must use their sending unit.

11. Passenger side O2.

12. Driver side O2.

13. Red plug with gray seal and green and red wire, is the Canister Purge. Only needed if doing

an

an emission emission legal legal system.system.

14. EGR Solenoid’s Black plug with gray seal and gray and black wires. Only needed if doing an emission legal system.

15. Orange wire with quick burn fusible link, goes to the hot battery starter. If you are using a battery disconnect you

must be on the hot side of the disconnect.

16. Gray plug with blue seal with five wires goes to the Lenoir EGR. ( Not needed in NON EMISSION applications.)

17. Blue wire with a black plug goes to the Knock Sensor.

18. Black plug with blue seal and light green and black wire, goes to the Engine Temp Sensor at

the front of the intake.

19. Dark brown wire is the HOT lead, to the electric fuel pump (fuse and relay is in the harness).

20. Black plug with blue seal and yellow and purple twisted wire, goes to the vehicle speed senor in the tail housing of

the transmission.

21. Black plug with blue seal and four wires, goes to

21. Black plug with blue seal and four wires, goes to the Idle Air Motor at the front of the intake.the Idle Air Motor at the front of the intake.

22. Black round plug with the

22. Black round plug with the purple seal, goes to purple seal, goes to the Throttle Position Sensor the Throttle Position Sensor

23. Injector plug goes to the main injector plug located behind the throttle body.

24. Gray plug with a purple seal and light green an

24. Gray plug with a purple seal and light green and gray wires, go to the MAPd gray wires, go to the MAPSensorSensor..

25. Black plug with purple seal and yellow, black, and red wires, go to the MASS AIR

25. Black plug with purple seal and yellow, black, and red wires, go to the MASS AIR FLOWFLOW..

26. Tan plug with purple seal and red, white and blue wires, go to the Coil.

27. Black plug with blue seal and red, white, black, and blue wires, go to the Coil Driver.

28. Black plug with purple seal and violet, yellow and red wires, go to the Crank Sensor

28. Black plug with purple seal and violet, yellow and red wires, go to the Crank Sensor ..

Street & Performance 5.0 / 5.7VORTEC

Std or 4L60E / 4L80E Transmission

(3)

28 28 1 1 2 2 4 4 6 6 5 5 77 3 3 8 8 10 10 27 27 26 26 9 9 24 24 25 25 23 23 21 21 22 22 28 28 20 20 19 19 17 17 18 18 16 16 12 12 1 111 13 13 14 14 15 15

Street & Performance

Small Block 5.0 / 5.7

VORTEC

Wiring Harness

4 Plugs to Computer 4 Plugs to Computer Red, Blue, Red, Blue,

Black and Gray.

Blue Plug Blue Plug Black Plug Black Plug White Plug White Plug Red Plug Red Plug

(4)

Canister Purge (13)

Canister Purge (13) Coil Module (27)Coil Module (27) Coil Plug (26)Coil Plug (26)

MA MAPP SeSensnsor or (24) (24) Injector Plug Injector Plug (23) (23) Fuel Inlet 16mm Fuel Inlet 16mm Fuel Return Fuel Return 14mm 14mm E.G.R Valve

E.G.R Valve _{Throttle Position}_{Throttle Position}

Sensor (22) Sensor (22) Idle Speed Idle Speed Motor (21) Motor (21) P.C.V (4)

P.C.V (4) Shrader valve toShrader valve to_{check fuel pressure}_{check fuel pressure}

Coolant Temp Coolant Temp (18) (18) Coil Plug (26) Coil Plug (26) C

Cooiil l DDrriivveer r ((2277)) MMAAPP SSeennssoor r ((2244)) Canister Purge (13)Canister Purge (13)

(NOTE:

AC

DELCO

EP

381 Fuel

Pump i

s needed

to suppl

y 65 P

.S.I

fuel pre

ssure.)

Small Block VORTEC

Manifold

(5)

Throttle Position

Sensor

Idle Speed Motor

Injector Plug

Vortec Distributor

These can be purchased NEW from Street & Performance

MAP

MAPSeSensonsor r

Big Block VORTEC

Manifold

(6)

Coolant Temp

Canister Purge Valve

Fuel Inlet

Return Fuel Line

Vacuum Fuel

Pressure Regulator

(NOTE:

AC

DELCO

EP

381 Fuel

Pump i

s needed

to suppl

y 65 P

.S.I f

uel pre

ssure.)

E.G.R Valve E.G.R Valve Coil Coil Injector Plug Injector Plug Injectors are Injectors are

located inside the

manifold.

(7)

GM 1996-00 4.3 / 5.0 / 5.7 / 7.4 VORTEC CPFI

E ENNGGIINNE E YYEEAARR CCOOMMPPUUTTEER R NNUUMMBBEERR 1 1999966--997 7 44..33LL 1166224444221100 11999966 1 166220088554466 11999966 1 166222299668844 11999977 1 1999988--000 0 44..33LL 1166225500227799 11999988 0 099335555669999 11999988 1 166226633449944 11999999--0000 1 1999966--997 7 55..0 0 / / 55..77LL 1166224444221100 11999966 1 166220088554466 11999966 1 166222299668844 11999977 1 1999988--000 0 55..0 0 / / 55..77LL 1166225500227799 11999988 0 099335555669999 11999988 1 166226633449944 11999999--0000 1 1999966--997 7 77..44LL 1166224444221100 11999966 1 166220088554466 11999966 1 166222299668844 11999977 1 1999988--000 0 77..44LL 1166225500227799 11999988 0 099335555669999 11999988 1 166226633449944 11999999--0000 3 3rrd d DDiiggiit t - - MMaakkee 44tth h DDiiggiitt 88tth h DDiiggiit t - - EEnnggiinnee 1100tth h DDiiggiit t - - YYeeaar r T T ((CChheevvrroolleett)) EE J J - - 77..44LL ((445544)) M M - - 5.05.0LL(30(305)5) R - 5. R - 5.7L7L(35(350)0) W - 4 W - 4.3L.3L(26(262)2) X - 4. X - 4.3L3L(26(262)2) T - 1996 T - 1996 V - 1997 V - 1997 W- 1998 W- 1998 X - 1999 X - 1999 Z - 2000 Z - 2000

VIN# I.D. IDENTIFIERS

(8)

GM BIG BLOCK VORTEC

INJECTOR ASSEMBLY

GM S

GM SMALLMALLBLOCK BLOCK VORTECVORTEC

INJECTOR ASSEMBLY INJECTOR ASSEMBLY GM V6 VORTEC GM V6 VORTEC INJECTOR ASSEMBLY INJECTOR ASSEMBLY INL

INLETET16m16mm O-Rm O-Ringing

RETURN 14mm O-Ring

LAR

LARGE FIGE FITTINTTINGG INLINLETET 16m16mm to Om to O-Rin-Ringg

14mm O-Ring Return

Regulator Return

(9)

17 17 18 18 23 23 21 21 22 22 24 24 25 25 2626 27 27 28 28 29 29 3030 35 35 34 34 33 33 32 32 31 31 20 20 19 19 13 13 12 12 16 16 15 15 1 111 14 14 5 5 ₆₆ 7 7 ₈₈ 99 4 4 3 3 ₂₂ 10 10 1 1

Street & Performance

Big Block VORTEC

Wiring Harness

4 Plugs to Computer

Red, Blue, Black and Gray.

(10)

Street & Performance

Big Block VORTEC 7.4 Std or 4L80E Transmission

1.

1. Fuel Fuel Pump Pump Relay.Relay. 2.

2. A.L.D.LA.L.D.L Connector Connector ( ( Diagnostic Diagnostic link link for for scanner).scanner). 3.

3. Fuse Fuse Panel.Panel. 4.

4. Ignition Switch (red Ignition Switch (red wire,12 volt wire,12 volt with key with key on and on and in stin start position).art position). 5.

5. TTachometer achometer (white (white wire).wire). 6.

6. 4000 Pulse 4000 Pulse vehicle speed vehicle speed signal for Speedometer signal for Speedometer (Green wire).(Green wire). 7.

7. Cruise Cruise Control (yellow Control (yellow wire).wire). 8.

8. Brake Light Switch Brake Light Switch (purple wire) Normally closed (purple wire) Normally closed for torque converter lockup.for torque converter lockup. 9.

9. Check Engine Light (brown wire) YCheck Engine Light (brown wire) You must supply 12 volts ou must supply 12 volts supply to 12 volt bulb, this wire is thesupply to 12 volt bulb, this wire is the ground side to complete the circuit.

ground side to complete the circuit. 10.

10. Black Black wire grwire ground to ound to back oback of block f block or heaor head. BEd. BESURE to SURE to clean clean contaccontact point.t point. Ground bGround battery to attery to engineengine or

or transmission, engine transmission, engine to to bodybody, and engine to frame., and engine to frame. 11.

11. Cam Sensor Cam Sensor (three prong plug, black (three prong plug, black with purple seal.with purple seal. 12.

12. Oil PressuOil Pressure wire (USED wire wire (USED with GM compath GM compatible gaugestible gauges, NOT, NOTUSED with any otheUSED with any other brand of gaugesr brand of gauges).). 13.

13. Oil Pressure sending unit ( Oil Pressure sending unit ( Part # 25036553 Part # 25036553 Three prong with brown and Three prong with brown and orange wire).orange wire). 14.

14. Direct to Direct to Fuel Pump Fuel Pump (brown wire).(brown wire). 15.

15. Cam Plug Cam Plug (Three prong plug (Three prong plug with purple with purple seal).seal). 16.

16. Coil Driver Coil Driver (Three prong plug (Three prong plug with blue with blue seal).seal). 17.

17. Driver side / Driver side / Passenger side Knock Passenger side Knock sensor wire sensor wire (blue wire).(blue wire). 18.

18. Hot fused link Hot fused link to main post to main post on starter on starter (orange wire).(orange wire). 19.

(11)

Street & Performance

Big Block VORTEC 7.4 Std or 4L80E Transmission

20. Passenger side injector plug (end plug has blue and red wires). 20. Passenger side injector plug (end plug has blue and red wires). 21. Passenger side Oxygen sensor (four prong plug).

21. Passenger side Oxygen sensor (four prong plug). 22. Driver side Oxygen sensor (four prong plug). 22. Driver side Oxygen sensor (four prong plug).

23. Engine Temp black plug with blue seal and yellow and black wire). 23. Engine Temp black plug with blue seal and yellow and black wire). 24. MAP

24. MAPSensor (gray plug with purplSensor (gray plug with purple seal 3 prong plug gray green black wie seal 3 prong plug gray green black wire).re). 25.

25. Lenoir E.GLenoir E.G.R(NOT USED on NON .R(NOT USED on NON EMISSION VEHICLES) (five prong gray plug with EMISSION VEHICLES) (five prong gray plug with purple seal).purple seal). 26. Canister purge (NOT USED on NON EMISSION VEHICLES)( two wire RED Plug).

26. Canister purge (NOT USED on NON EMISSION VEHICLES)( two wire RED Plug).

27. E.G.R solenoid (NOT USED on NON EMISSION VEHICLES)( black two prong plug with gray seal). 27. E.G.R solenoid (NOT USED on NON EMISSION VEHICLES)( black two prong plug with gray seal). 28. Idle Air Speed (Four prong black plug with blue seal).

28. Idle Air Speed (Four prong black plug with blue seal).

29. Throttle Position Sensor (round three prong plug with purple seal). 29. Throttle Position Sensor (round three prong plug with purple seal).

30. Vehicle Speed output (black Plug with blue seal and twisted yellow and purple wire). 30. Vehicle Speed output (black Plug with blue seal and twisted yellow and purple wire). 31. Vehicle Speed input (black Plug with blue seal and twisted blue and red wire).

31. Vehicle Speed input (black Plug with blue seal and twisted blue and red wire). 32. 4L80E Transmission plug (large gray plug).

32. 4L80E Transmission plug (large gray plug).

33. MAF (three prong black plug with purple seal, red, yellow and black wire). 33. MAF (three prong black plug with purple seal, red, yellow and black wire). 34. Air Temp Sensor (gray plug blue seal, black and brown wire).

34. Air Temp Sensor (gray plug blue seal, black and brown wire).

35 Crank Sensor ( black plug with purple seal with red, purple and yellow wires). 35 Crank Sensor ( black plug with purple seal with red, purple and yellow wires).

(12)

DTC P0101 Mass Air Flow System Performance DTC P0101 Mass Air Flow System Performance DTC P0102

DTC P0102 MAFMAF Sensor CiSensor Circuit Low Frercuit Low Frequencyquency DTC P0103

DTC P0103 MAFMAF Sensor CiSensor Circuit High Frercuit High Frequencyquency DTC P010

DTC P0106 MAP6 MAPSystem System PerformancPerformancee DTC P0107 MAP

DTC P0107 MAPSensor CircuiSensor Circuit Low Volt Low Voltagetage DTC P0108 MAP

DTC P0108 MAPSensor CircuiSensor Circuit high Volt high Voltagetage DTC P0112 IAT Sensor Circuit Low Voltage DTC P0112 IAT Sensor Circuit Low Voltage DTC P0113 IAT Sensor Circuit High Voltage DTC P0113 IAT Sensor Circuit High Voltage DTC P0117 ECT Sensor Circuit Low Voltage DTC P0117 ECT Sensor Circuit Low Voltage DTC P0118 ECT Sensor Circuit High Voltage DTC P0118 ECT Sensor Circuit High Voltage DTC P012

DTC P0121 TP1 TPSensor Sensor PerformancPerformancee DTC P0122 TP

DTC P0122 TP Sensor CircuSensor Circuit Low Voit Low Voltageltage DTC P0123 TP

DTC P0123 TP Sensor CircuSensor Circuit High Voit High Voltageltage DTC P0125 ECT Excessive Time to Closed Loop DTC P0125 ECT Excessive Time to Closed Loop

DTC P0131 HO2S Circuit Low Voltage Bank 1 Sensor 1 DTC P0131 HO2S Circuit Low Voltage Bank 1 Sensor 1 DTC P0132 HO2S Circuit High Voltage Bank 1 Sensor 1 DTC P0132 HO2S Circuit High Voltage Bank 1 Sensor 1 DTC P0133 HO

DTC P0133 HO2S Slow Resp2S Slow Response Bank 1 Seonse Bank 1 Sensornsor 11 DTC P0134 HO2S Insufficient Activity Bank 1 Sensor 1 DTC P0134 HO2S Insufficient Activity Bank 1 Sensor 1 DTC P0135 HO2S Heater Circuit Bank 1 Sensor 2

DTC P0135 HO2S Heater Circuit Bank 1 Sensor 2

DTC P0137 HO2S Circuit Low Voltage Bank 1 Sensor 2 DTC P0137 HO2S Circuit Low Voltage Bank 1 Sensor 2 DTC P0138 HO2 S Circuit High Voltage bank 1 Sensor 2 DTC P0138 HO2 S Circuit High Voltage bank 1 Sensor 2 DTC P0140 HO2S Insufficient Activity Bank 1 Sensor 2 DTC P0140 HO2S Insufficient Activity Bank 1 Sensor 2 DTC P0141 HO2S Heater Circuit Bank 1 Sensor 2

DTC P0141 HO2S Heater Circuit Bank 1 Sensor 2 DTC P0143 HO2S Circ

DTC P0143 HO2S Circuit Low Vuit Low Voltage Banoltage Bank 1 Sensork 1 Sensor33 DTC P0144 HO2S Circuit High Voltage Bank 1 Sensor 3 DTC P0144 HO2S Circuit High Voltage Bank 1 Sensor 3 DTC P0146 HO2S Insufficient Activity Bank 1 Sensor 3 DTC P0146 HO2S Insufficient Activity Bank 1 Sensor 3 DTC P0147 HO2S Heater Circuit Bank 1 Sensor 3

DTC P0151 HO2S Circuit Low Voltage Bank 2 Sensor 1 DTC P0151 HO2S Circuit Low Voltage Bank 2 Sensor 1 DTC P0152 HO2S Circuit High Voltage Bank 2 Sensor 1 DTC P0152 HO2S Circuit High Voltage Bank 2 Sensor 1 DTC P0153 HO2S Slow Response Bank 2 Sensor 1 DTC P0153 HO2S Slow Response Bank 2 Sensor 1 DTC P0154 HO2S Insufficient Activity Bank 2 Sensor 2 DTC P0154 HO2S Insufficient Activity Bank 2 Sensor 2 DTC P0155 HO2S Heater Circuit Bank 2 Sensor 1

DTC P0157 HO2S Circuit Low Voltage Bank 2 Sensor 2 DTC P0157 HO2S Circuit Low Voltage Bank 2 Sensor 2 DTC P0158 HO2S Circuit High Voltage Bank 2 Sensor 2 DTC P0158 HO2S Circuit High Voltage Bank 2 Sensor 2 DTC P0160 HO2S Insufficient Activity Bank 2 Sensor 2 DTC P0160 HO2S Insufficient Activity Bank 2 Sensor 2 DTC P0161 HO2S Heater Circuit Bank 2 Sensor 2

DTC P0161 HO2S Heater Circuit Bank 2 Sensor 2 DTC P01

DTC P0171 Fue71 Fuel Trl Trim Sysim System Leatem Leann BankBank11 DTC P0172 Fuel Trim System Rich Bank 1 DTC P0172 Fuel Trim System Rich Bank 1 DTC P0174 Fuel Trim System Lean Bank 2 DTC P0174 Fuel Trim System Lean Bank 2 DTC P0175 Fuel Trim System Rich Bank 2 DTC P0175 Fuel Trim System Rich Bank 2 DTC P0300 Engine Misfire Detected

DTC P0300 Engine Misfire Detected DTC P0301 Cylinder 1 Misfire Detected DTC P0301 Cylinder 1 Misfire Detected DTC P0302 Cylinder 2 Misfire Detected DTC P0302 Cylinder 2 Misfire Detected DTC P0303 Cylinder 3 Misfire Detected DTC P0303 Cylinder 3 Misfire Detected DTC P0304 Cylinder 4 Misfire Detected DTC P0304 Cylinder 4 Misfire Detected

VORTEC

D

T

C

D

(13)

DTC P0305 Cylinder 5 Misfire Detected DTC P0305 Cylinder 5 Misfire Detected DTC P0306 Cylinder 6 Misfire Detected DTC P0306 Cylinder 6 Misfire Detected DTC P0307 Cylinder 7 Misfire Detected DTC P0307 Cylinder 7 Misfire Detected DTC P0308 Cylinder 8 Misfire Detected DTC P0308 Cylinder 8 Misfire Detected DTC P0325 Knock Sensor Circuit

DTC P0325 Knock Sensor Circuit

DTC P0327 Knock Sensor Noise Channel Low Voltage DTC P0327 Knock Sensor Noise Channel Low Voltage DTC P033

DTC P0336 CKP6 CKPSensor CiSensor Circuit Perforrcuit Performancemance DTC P0337 CK

DTC P0337 CKPPSensor CircSensor Circuit Low Frequenuit Low Frequencycy DTC P0338 CK

DTC P0338 CKPPSensor CircSensor Circuit High Frequenuit High Frequencycy DTC P033

DTC P0339 CKP9 CKPSensor CiSensor Circuit Intermrcuit Intermittentittent DTC P0

DTC P0340 CM340 CMPPSensor Sensor CircuitCircuit DTC P034

DTC P0341 CMP1 CMPSensor CiSensor Circuit Perforrcuit Performancemance DTC P0401 EGR System Flow Insufficient DTC P0401 EGR System Flow Insufficient DTC P0410 AIR System

DTC P0410 AIR System

DTC P0420 TWC System Low Efficiency Bank 1 DTC P0420 TWC System Low Efficiency Bank 1 DTC P0430 TWC System Low Efficiency Bank 2 DTC P0430 TWC System Low Efficiency Bank 2 DTC P04

DTC P0440 EV40 EVAPAP SystemSystem DTC P0441 EV

DTC P0441 EVAPAP System No Flow During PurgSystem No Flow During Purgee DTC P0442 EV

DTC P0442 EVAPAP Control System SmControl System Small Leak Detectedall Leak Detected DTC P0446 EV

DTC P0446 EVAPAP Canister VCanister Vent Blockedent Blocked

DTC P0461 Fuel Level Sensor Circuit Performance DTC P0461 Fuel Level Sensor Circuit Performance DTC P0462 Fuel Level Sensor Circuit Low Voltage DTC P0462 Fuel Level Sensor Circuit Low Voltage DTC P0463 Fuel Level Sensor Circuit High Voltage DTC P0463 Fuel Level Sensor Circuit High Voltage DTC P0500 Vehicle Speed Sensor Circuit

DTC P0500 Vehicle Speed Sensor Circuit DTC P0506 Idle Control System Low RPM DTC P0506 Idle Control System Low RPM DTC P0507 Idle Control System High RPM DTC P0507 Idle Control System High RPM DTC P0704 Clutch Switch Circuit

DTC P0704 Clutch Switch Circuit DTC P11

DTC P1106 MAP06 MAPSensor CKT Intermittent High VSensor CKT Intermittent High Voltageoltage DTC P11

DTC P1107 MAP07 MAPSensor CKT Intermittent Low VSensor CKT Intermittent Low Voltageoltage DTC P1111 IAT Sensor CKT Intermittent High Voltage DTC P1111 IAT Sensor CKT Intermittent High Voltage DTC P1112 IAT Sensor CKT Intermittent Low Voltage DTC P1112 IAT Sensor CKT Intermittent Low Voltage DTC P1114 ECT Sensor CKT Intermittent Low Voltage DTC P1114 ECT Sensor CKT Intermittent Low Voltage DTC P1115 ECT Sensor CKT Intermittent High Voltage DTC P1115 ECT Sensor CKT Intermittent High Voltage DTC P11

DTC P1121 TP21 TP Sensor CKT IntermittenSensor CKT Intermittent High Voltt High Voltageage DTC P11

DTC P1122 TP22 TP Sensor CKT IntermittenSensor CKT Intermittent Low Voltt Low Voltageage DTC P1133 HO2S Insufficient Switching Bank 1 Sensor 1 DTC P1133 HO2S Insufficient Switching Bank 1 Sensor 1 DTC P1134 HO2S Transition Time Ratio Bank 1 Sensor 1 DTC P1134 HO2S Transition Time Ratio Bank 1 Sensor 1 DTC P1153 Insufficient Switching Bank 2 Sensor 1

DTC P1153 Insufficient Switching Bank 2 Sensor 1

DTC P1154 HO2S Transition Time Ratio Bank 2 Sensor 1 DTC P1154 HO2S Transition Time Ratio Bank 2 Sensor 1 DTC P

DTC P1345 1345 CKP/CMPCKP/CMPCorrelationCorrelation DTC P1351 IC Circuit High Voltage DTC P1351 IC Circuit High Voltage DTC P1361 ID Circuit Low Voltage DTC P1361 ID Circuit Low Voltage

DTC P1380 EBCM DTC Rough Road Date Unusable DTC P1380 EBCM DTC Rough Road Date Unusable DTC P1381 Misfire Detected No EBCM/VCM Serial Data DTC P1381 Misfire Detected No EBCM/VCM Serial Data DTC P1406 EGR Valve Pintle Position Circuit

DTC P1406 EGR Valve Pintle Position Circuit DTC P1415 AIR System Bank 1

DTC P1415 AIR System Bank 1 DTC P141

DTC P1416 AIR6 AIRSystem BaSystem Bank 2nk 2 DTC P1441 EV

DTC P1441 EVAPAP System Flow DurinSystem Flow During Non-Purgeg Non-Purge DTC P1508 IAC System Low RPM

DTC P1508 IAC System Low RPM DTC P1509 IAC System High RPM DTC P1509 IAC System High RPM

(14)

OT

OTHE

HER

R

VO

VORT

RTEC

EC PR

PROD

ODUC

UCTS

TS

A

V

AI

AILA

LA

BL

BLE

E

FR

FROM

OM

S

ST

TRE

RE

E

ET

T

&

P

PE

ERF

RFOR

OR

MA

MANC

NCE

E

Ph. 479-394-5711

Fax. 479-394-7113

S&P

S&Pcan pcan provirovide yode youu

with Quality AC Delco

Parts, saving you from

having to go to the part

store and assuring that

you have the right parts.

Custom length braided fuel lines made to fit your

application with quality Aeroquip performance products. S&P

stocks a complete line of hoses and fittings for fuel lines and

power steering.

AC

ACDELDELCO O2 SeCO O2 Sensonsorsrs

Street & Performance

Fuel Filter Kit.

Includes Genuine AC Delco Fuel

Filter, Street & Performance

Filter Bracket and Fittings.

VORTEC Computers

are black with five

plugs. The 94-97 LT-1

computers are silver

with four connection

plugs.

Small

Small Plug Plug Not Not UsedUsed

I.D Service Number

Polished Fuel Line Fittings

16mm O-Ring to AN6

14mm O-Ring to AN6

(15)

#1 Hot Rod Lane

Mena, Arkansas 71953

Ph. 479-394-5711 Fax. 479-394-7113

www.hotrodlane.cc

Hook to red brake wire

12 V

12 Voltolts As ALLLLTHTHEE TIMTIMEE

with brake OFF.

NO V

NO VOLOLTTAGAGEE WIWITHTHBRBRAKAKEE ONON!!

12 Volts In

12 Volts In _{12 Volts In}_{12 Volts In}

For brake light

12 Volts with brake on ONLY

GM Brake Switch #25524845

AC Delco #D850A

If you have a 2 prong pressure brake switch, you will need this

brake switch relay kit.