Safety Data Sheet
Issue Date: 25-Nov-2019 Review Date: 26-Nov-2019 Version 1
1. IDENTFICATION
Product Identifier
Product Name Coastal Full Synthetic SAE 75W-80 Other means of identification
SDS # WUI086
Recommended use of the chemical and restrictions on use
Recommended Use Lubricating Oil
Details of the supplier of the safety data sheet Supplier Address
Warren Oil Company 915 E. Jefferson Ave. West Memphis, AR 72301 Emergency Telephone Number
Company Phone Number 1-800-428-9284
Emergency Telephone (24 hr) Chemtrec 1-800-424-9300 (North America) 1-703-527-3887 (International)
2. HAZARDS IDENTIFICATION
GHS Classification
This material is not considered hazardous under the OSHA Hazard Communication Standard (HazCom 2012).
GHS Label Elements
This material is not considered hazardous under the OSHA Hazard Communication Standard (HazCom 2012).
Other Hazards None known.
3. COMPOSITION/INFORMATION ON INGREDIENTS
This material is defined as a mixture. Hazardous Components
Chemical Name CAS # Classification Concentration (%)
POLYOLEFIN PHOSPHORIC ACID ESTER Skin Irrit. 2; H315 <5
4. FIRST-AID MEASURES
General Advice No hazards which require special first aid measures.
If Inhaled If breathed in, move person to fresh air. If unconscious, place in recovery position and seek medical advice. If symptoms persist, call a physician.
In Case of Eye Contact Flush eyes with water as a precaution. Remove contact lenses. Protect unharmed eye. If eye irritation persists, consult a specialist.
If Swallowed IF SWALLOWED: Call a POISON CENTER/doctor if you feel unwell. Do not give milk or alcoholic beverages. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician.
Most Important Symptoms and
Effects, Both Acute and Delayed No symptoms known or expected.
Notes to Physician No hazards which require special first aid measures.
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media: Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Water spray, foam, carbon dioxide (co2), dry chemical.
Unsuitable Extinguishing Media: High volume water jet. Specific Hazards during
firefighting: Do not allow run-off from firefighting to enter drains or water courses. Hazardous Combustion
Products: Carbon Dioxide and Carbon Monoxide, Oxide of phosphorus. Specific Extinguishing Methods: Product is compatible with standard firefighting agents.
Further Information: Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations.
Special Protective Equipment
For Firefighters: In the event of fire, wear self-contained breathing apparatus.
6. ACCIDENTAL RELEASE MEASURES
Person Precautions, Protective Equipment and Emergency Procedures:
Use personal protective equipment. Persons not wearing protective equipment should be excluded form area of spill until clean-up has been completed.
Environmental Precautions:
Prevent product from entering drains. Prevent further leakage or spillage if safe to do so. If the product contaminates rivers and lakes or drains, inform respective authorities.
Methods and Materials for Containment and Cleaning Up:
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Keep in suitable, closed containers for disposal.
Other Information:
Comply with all applicable federal, state and local regulations.
7. HANDLING AND STORAGE
Advice on Safe Handling:
Avoid contact with skin and eyes. Smoking, eating and drinking should be prohibited in the application area. For personal protection see section 8. Dispose of rinse water in accordance with local and national regulations.
Conditions for Safe Storage:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with Workplace Control Parameters
Contains no substances with occupational exposure limit values.
Hazardous Components without Workplace Control Parameters
Components CAS-No.
Polyolefin Phosphoric Acid Ester
Engineering Measures:
Provide sufficient mechanical (general and/or local exhaust) ventilation to maintain exposure below exposure guidelines (if applicable) or below levels that cause known, suspected or apparent adverse effects.
Personal Protective Equipment
Hand Protection Measures: Nitrile rubber butyl-rubber. The suitability for a specific workplace should be discussed with the producers of the protective gloves.
Eye Protection: Not required under normal conditions of use. Wear splash-proof safety goggles if material could be misted or splashed into eyes.
Skin and Body Protection: Wear as appropriate: Impervious clothing, safety shoes, choose body protection according to the amount and concentration of the dangerous substance at the work place. Wear resistant gloves (consult your safety equipment supplier).
Hygiene Measures: Wash hands before breaks and at the end of the workday. When using do not eat or drink. When using do not smoke.
9. PHYSICAL AND CHEMICAL PROPERTIES
Information on basic physical and chemical properties Physical State Liquid
Color Red
Odor No data available
Odor Threshold No data available
Properties Values
pH No data available
Pour Point <-54°F / -48°C
Boiling point/boiling range No data available
Flash point 428°F / 220°C
Evaporation rate No data available
Flammability (solid, gas) No data available Upper explosion limit No data available Lower explosion limit No data available
Vapor pressure No data available
Relative vapor density No data available
Relative Density No data available
Solubility(ies):
Water solubility No data available
Solubility in other solvents No data available Partition coefficient:
n-octanol/water No data available
Properties Values
Viscosity, dynamic No data available Viscosity, kinematic No data available
Oxidizing Properties No data available
10. STABILITY AND REACTIVITY
Reactivity: No decomposition if stored and applied as directed.
Chemical Stability: Stable under recommended storage conditions.
Possibility of Hazardous
Reactions: Product will not undergo hazardous polymerization.
Conditions to Avoid: None known.
Incompatible materials: None known.
Hazardous decomposition
Products: Carbon dioxide and carbon monoxide, Oxides of phosphorus.
11. TOXICOLOGICAL INFORMATION
Information on likely routes of exposure: Inhalation, Skin Contact, Eye Contact, Ingestion
Acute Toxicity
Not classified based on available information. Product: Acute oral toxicity: LD50: > 5,000mg/kg
Skin Corrosion/Irritation
Not classified based on available information. Components: Polyolefin Phosphoric Acid Ester: Result: Irritating to skin.
Serious Eye Damage/Eye Irritation Not classified based on available information.
Product: Vapors may cause irritation to the eyes, respiratory system and the skin. Components: Polyolefin Phosphoric Acid Ester:
Result: Slight, transient irritation.
Respiratory or Skin Sensitization
Skin sensitization: Not classified based on available information. Respiratory sensitization: Not classified based on available information. Germ cell mutagenicity: Not classified based on available information. Carcinogenicity
Not classified based on available information.
Reproductive toxicity
Not classified based on available information. STOT – Single exposure
Not classified based on available information.
Not classified based on available information.
Aspiration toxicity
Not classified based on available information.
Further Information:
Product: No data available. Carcinogenicity:
IARC: No component of this product present at levels greater than or equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.
OSHA: No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA.
NTP: No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP.
12. ECOLOGICAL INFORMATION
Ecotoxicity Product: Toxicity to Fish: LC50: 10 – 100 mg/l Toxicity to Bacteria: EC0: 10 – 100 mg/lEcotoxicity Assessment Acute Aquatic Toxicity: Acute aquatic toxicity Category 3; Harmful to aquatic life. Chronic aquatic toxicity: Chronic aquatic toxicity Category 3; Harmful to aquatic life with long lasting effects.
Persistence and degradability
Product:
Biodegradability: Remarks: Not readily biodegradable. No data available. Biodegradation: No data available.
Mobility in Soil: No data available. Other Adverse Effects: No data available.
Product:
Additional Ecological Information: An environmental hazard cannot be excluded in the event of unprofessional handling or disposal. Harmful to aquatic life with long lasting effects.
13. DISPOSAL CONSIDERATIONS
Disposal Methods
General Advice: The product should not be allowed to enter drains, water courses or the soil. Do not combine ponds, waterways or ditches with chemical or used container. Send to a licensed waste management company. Dispose of in accordance with all applicable local, state and federal regulations.
Contaminated Packaging: Empty remaining contents. Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not re-use empty containers.
International Transport Regulations
Regulation ID Number
Proper Shipping Name *Hazard Class
Subsidiary Hazards Packing Group
Marine Pollutant / LTD. QTY.
U.S. DOT – ROAD Not dangerous goods
CFR_RAIL_C Not dangerous goods
U.S. DOT – INLAND WATERWAYS Not dangerous goods
TDG_ROAD_C Not dangerous goods
TDG_RAIL_C Not dangerous goods
TDG_INWT_C Not dangerous goods
INTERNATIONAL MARITIME DANGEROUS GOODS Not dangerous goods
INTERNATIONAL AIR TRANSPORT ASSOCIATION – CARGO Not dangerous goods
INTERNATIONAL AIR TRANSPORT ASSOCIATION – PASSENGER Not dangerous goods
MX_DG
Not dangerous goods
*ORM=ORM-D, CBL=COMBUSTIBLE LIQUID
Marine Pollutant No
Dangerous goods descriptions (if indicated above) may not reflect quantity, end-use or region-specific exceptions that can be applied. Consult shipping documents for descriptions that are specific to the shipment.
15. REGULATORY INFORMATION
EPCRA – Emergency planning and Community Right-to-Know Act
CERCLA REPORTABLE QUANTITY
This material does not contain any components with a CERCLA RQ.
SARA 311/312 Hazards No SARA hazards
SARA 313
This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313
California Prop 65
This product does not contain any chemicals known to State of California to cause cancer, birth defects, or any other reproductive harm.
The Components of this product are reported in the following inventories: DSL: All components of this product are on the Canadian DSL.
AICS: On the inventory, or in compliance with the inventory ENCS: Not in compliance with the inventory
KECI: Not in compliance with the inventory PICCS: Not in compliance with the inventory
IECSC: On the inventory, or in compliance with the inventory TSCA: On TSCA inventory
Inventories:
AICS (Australia), DSL (Canada), IECSC (China), REACH (European Union), ENCS (Japan), IHSL (Japan), KECI (Korea), NZIoC (New Zealand), PICCS (Philippines), TCSI (Taiwan), TSCA (USA)
16. OTHER INFORMATION
Further Information Revision Date: 11/26/2019 NFPA: HMIS III: HEALTH 0 FLAMMABILITY 1 PHYSICAL HAZARD 0 0 = not significant, 1= slight, 2 = Moderate, 3 = High 4 = Extreme, * = ChronicNFPA Flammable and Combustible Liquids Classification Combustible Liquid Class IIIB.
List of abbreviations and acronyms used in this safety data sheet CAS: Chemical Abstract Service (Division of the American Chemical Society) GHS: Globally Harmonized System of Classification and Labeling of Chemicals H-Statement: Hazard Statement
LCxx: Lethal Concentration, for xx percent of test population LDxx: Lethal Dose, for xx percent of test population
ECxx: Effective Concentration of xx STOT: Specific Target Organ Toxicity
CERCLA: Comprehensive Environmental Response, Compensation, and Liability Act DOT: Department of Transportation
NFPA: National Fire Protection Association
OSHA: Occupational Safety and Health Administration
THIS SAFETY DATA SHEET CONTAINS THE FOLLOWING REVISIONS: Updates made in accordance with implementation of GHS requirements.
Issue Date: 25-Nov-2019
Review Date: 26-Nov-2019
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text.