HILUX ELECTRICALSUP. EWD378F

Full text

(1)Back To Electrical Index EWD378F. CK TO MAIN MODELFOREWORD IND. TOYOTA MOTOR CORPORATION. VIEW THE MAIN INDEX Pages From Supplement TO MODEL INDEX. This supplement provides information covering changes in the Electrical System specifications of the HILUX which were made in JULY, 1999.. Applicable models: E1999 TOYOTA MOTOR CORPORATION All rights reserved This CD may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.. RZN142, 144, 147, 148, 149, 154, 168, 169, 173, 174, 193 Series KZN165 Series LN 141, 145, 146, 147, 150, 152, 165, 166, 167, 170, 171, 172, 190, 191 Series. For information which is not mentioned in this manual, please refer to the following Electrical Wiring Diagram Manuals:. Manual Name D HILUX Electrical Wiring Diagram D HILUX Chassis and Body Repair Manual Supplement D 1KZ-TE Engine Repair Manual. Pub. No. EWD307F RM706E RM710E. All information in this manual is based on the latest product information at the time of publication. However, specifications and procedures are subject to change without notice.. NOTICE When handling supplemental restraint system components (removal, installation or inspection, etc.), always follow the direction given in the repair manuals listed above to prevent accidents and supplemental restraint system malfunction..

(2) BACK TO MAIN FOREWORD & Electrical Index. EWD378F Pages From Supplement TO MODEL INDEX. MAIN INDEX: HILUX. ELECTRICAL WIRING DIAGRAM : Supp. (English). July 1999. Section No.. Page. INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . .. 5. HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . . . . . . . . . . B . . . .. 6. ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C . . . .. 8. RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D . . . .. 22. ELECTRICAL WIRING ROUTING . . . . . . . . . . . . . . . . . . . . . . . E . . . .. 34. CONNECTOR LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . F . . . .. 112. PART NUMBER OF CONNECTORS . . . . . . . . . . . . . . . . . . . . . H . . . .. 150. OVERALL ELECTRICAL WIRING DIAGRAM .LHD .............I ..... 154. OVERALL ELECTRICAL WIRING DIAGRAM .RHD .............I. 194. 1 HILUX (EWD378F).

(3) EWD378F Pages From Supplement TO MODEL INDEX. BACK TO MAIN INDEX. INTRODUCTION A This manual consists of the following 9 sections: No.. Section. Description. INDEX. Index of the contents of this manual.. INTRODUCTION. Brief explanation of each section.. B. HOW TO USE THIS MANUAL. Instructions on how to use this manual.. C. ABBREVIATIONS. Defines the abbreviations used in this manual.. D. RELAY LOCATIONS. Shows position of the Electronic Control Unit, Relays, Relay Block, etc. This section is closely related to the wiring diagram.. E. PARTS LIST. List of part names used in this manual.. F. CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS. Shows connector joining wire harness and wire harness described in this manual.. G. CONNECTOR LIST. Describes the form of the connectors for the parts appeared in this book. This section is closely related to the wiring diagram.. H. PART NUMBER OF CONNECTORS. Indicates the part number of the connectors used in this manual.. I. OVERALL ELECTRICAL WIRING DIAGRAM. Provides circuit diagrams showing the circuit connections.. A. 5 HILUX (EWD378F).

(4) W-R. W-R. W. W. R 2 B. 2 A. B-L W-B. (2L-T) B-W. 6. HILUX (EWD378F) B-W. (22R-E). 40A AM1. 100A ALT B-W. W-R. W-R. W-R. W-R. W-R. Left front fender. 1 W-R. W-B EA. 2 F37 M FUEL PUMP 1. R-G. 16 BS1. R-W. R-G. 4 EA3 17 EA3. L-Y. BR. T1 P. O. N. M. L. K. J. 3. W-R. 30A AM2. EC. BR. S. R. GR-B E1 VF Q. G-Y. OX1 1Y-R FP +B. 7. 4 Y-R. D1 DATA LINK CONNECTOR 1. 2. 5 G-R. BR. W-B Left kick ID panel. BR. 6 G. V5 VOLUME AIR FLOW METER 3 1 BR-W. Y-R. H. G. F. E. I (22R-E). B. D. C. [J]. 8. 9. Y-R. Y-R. GR. BR. B. R-Y. W-R. GR-B. G-Y. L-Y. G-R. G. BR-W. Intake manifold RH. 21 EA3. B4. 6. Y-R. R. B-L. [L]. Y-R. Left front fender. I11 NO. 3. [K]. 1. B-R W-R. 1. I10 NO. 2. 1. 2. 5 BO2. W-B 4 6. C19 CIRCUIT OPENING RELAY. R-G. STARTER. B-R. 2. B-R 2. B-R I12 NO. 4. 2. R-G. S39 B. S38 A. INJECTOR. B-R. Y-R. 1 A. S37 START INJECTOR TIME SW. 1. 3. B-W. Y-R. 1 GR H11 HEATED OXYGEN SENSOR. 2. B3. 4. BR. K2 KNOCK SENSOR B1. B. A. (Shielded). 1 B. (2L-T). B-W 2. 153C. 2. EFI MAIN RELAY. [E]. R-G. B-W. 1. 1. C24 COLD START INJECTOR. ;;;;;; ;;;;;; ;;;;;; [F]. 1. R-G. 6 EA4. [D]. 2. W-B. 1 Y-R. 2. 4. 1. Y-R. EA. 1 B. (2L-T). 1 A. 73C. R-Y. 15A EFI. 4. Y-R. BATTERY. B. B. STARTER RELAY. A. S41. (2L-T). S40. [I] 1. 3. 1. [H]. 3. B HOW TO USE THIS MANUAL. 2. [C]. B-W B-W(22R-E). B-W. To Emission ECU <9-8>. 12 EA1. B-R. 2. B-W B-W. [G]. 7. 5A IGN. B-W. 2. (22R-E) 7 EA3. B-L. B-R. (2L-T). (22R-E) (2L-T). B-L. B-W. W. 2 A. B-W. ST2. 7. 5A ST. B-R. Engine Control. R-Y. [B]. AM2. B-R. B-W. 2. Starting. W-R Y-R. 2. 5 W-R A. 1 4 B A. 7 IG2 B. ST1. A B ACC I 6 , IGNITION SW IG1. [A]. B-R. 8 B. 1 4 AM1 W A B. 1. Power Source. * The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the wiring diagram section.. English. HOW TO READ THIS SECTION. BACK TO MAIN INDEX EWD378F Pages From Supplement TO MODEL INDEX. BR. BR. W-B. W-R. I9 NO. 1. B-W G.

(5) HILUX (EWD378F). Y (Yellow). Male. Numbered in order from upper right to lower left. Indicates Relay Block No.1. [F] : Junction Block (The number in the circle is the J/B No. and the connector code is shown beside it). Junction Blocks are shaded to clearly separate them from other parts.. Example:. Male (. ). ).. : ( ) is used to indicate different wiring and connector, etc. when the vehicle model, engine type, or specification is different.. Junction Connector. Same Color. Short Terminal. Junction connector in this manual include a short terminal which is connected to a number of wire harnesses. Always perform inspection with the short terminal installed. (When installing the wire harnesses, the harnesses can be connected to any position within the short terminal grouping. Accordingly, in other vehicles, the same position in the short terminal may be connected to a wire harness from a different part.) Wire harness sharing the same short terminal grouping have the same color.. HINT :. [L] : The same code occuring on the next page indicates that the wire harness is continuous.. [K] : Indicates and located on ground point.. [J] : Indicates a shielded cable.. ;;;; ;;;; 3C indicates ;;;; that it is inside ;;;; Junction Block ;;;; No.3 ;;;; ;;;;. Example. [E] : Indicates a Relay Block. No shading is used and only the Relay Block No. is shown to distinguish it from the J/B.. The numbering system for the overall wiring diagram is the same as above.. Female. Example: Numbered in order from upper left to lower right. [C] : The position of the parts is the same as shown in the wiring diagram and wire routing. [D] : Indicates the pin number of the connector. The numbering system is different for female and male connectors.. L (Blue). [I]. Female. [G] : Indicates related system. [H] : Indicates the wiring harness and wiring harness connector. The wiring harness with male terminal is shown with arrows ( Outside numerals are pin numbers.. English. [A] : System Title [B] : Indicates the wiring color. Wire colors are indicated by an alphabetical code. B = Black W = White BR = Brown L = Blue V = Voilet SB = Sky Blue R = Red G = Green LG = Light Green P = Pink Y = Yellow GR = Gray O = Orange Example: L - Y The first letter indicates the basic wire color and the second letter indicates the color of the stripe.. CLICK HERE TO VIEW CHAPTER INDEX. B. EWD378F Pages From Supplement TO MODEL INDEX. 7.

(6) EWD378F Pages From Supplement TO MODEL INDEX. BACK TO MAIN INDEX. C ABBREVIATIONS ABBREVIATIONS The following abbreviations are used in this manual.. English. ABS. =. Anti-Lock Brake System. A/C. =. Air Conditioner. ADD. =. Automatic Disconnecting Differential. A/T. =. Automatic Transmission. BACS. =. Boost Altitude Compensational Stopper. COMB. =. Combination. DIFF.. =. Differential. DLC3. =. Data Link Connector 3. ECT. =. Electronically Controlled Transmission. ECU. =. Electronic Control Unit. EFI. =. Electronic Fuel Injection. EGR. =. Exhaust Gas Recirculation. EVAP. =. Evaporative Emission. G.C.C.. =. Gulf Cooperation Council. IIA. =. Integrated Ignition Assembly. ISC. =. Idle Speed Control. LH. =. Left-Hand. LHD. =. Left-Hand Drive. M/T. =. Manual Transmission. O/D. =. Overdrive. RH. =. Right-Hand. RHD. =. Right-Hand Drive. SRS. =. Supplemental Restraint System. SW. =. Switch. TEMP.. =. Temperature. VRV. =. Vacuum Regulating Valve. VSV. =. Vacuum Switching Valve. w/. =. With. w/o. =. Without. 2WD. =. Two Wheel Drive Vehicles. 4WD. =. Four Wheel Drive Vehicles. ∗ The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being abbreviations.. 8 HILUX (EWD378F).

(7) BACK TO MAIN INDEX. RELAY LOCATIONS: ENGINE COMPARTMENT: Pg 22 1.LHD Pg 22 INSTRUMENT PANEL Pg 22 1.LHD Pg22 ENGINE COMPARTMENT: Pg 23 1.RHD Pg 23 INSTRUMENT PANEL Pg 23 1.RHD Pg23 DRIVER SIDE J/B Pg 24 LHD Pg24 DRIVER SIDE J/B INNER CIRCUIT LHD Pg 25 DRIVER SIDE J/B Pg 26 RHD Pg26 DRIVER SIDE J/B INNER CIRCUIT RHD Pg 27 CENTER J/B Pg28 RHD AUSTRALIA Pg28 CENTER J/B INNER CIRCUIT Pg29 ENGINE ROOM R/B: Pg 30 ENGINE ROOM R/B No.2 Pg 31 R/B No.5 Pg31 R/B No.6 RHD w/DIM-DIP LIGHT Pg32 PASSENGER SIDE R/B Pg32: RHD 3RZ-FE, 1RZ-E, 1KZ-TE Pg 32 R/B No.8 ISRAEL Pg 33. EWD378F Pages From Supplement TO MODEL INDEX.

(8) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS [Engine Compartment] (LHD). Headlight Cleaner Relay. R/B No.5. Engine Room R/B. Engine Room R/B No.2 (Diesel). R/B No.8 (Israel). CLICK HERE TO VIEW CHAPTER INDEX. [Instrument Panel] (LHD). Daytime Running Light Relay •Emission Control ECU (3RZ-F, 1RZ, Europe 2L-T, 2L) •Engine ECU (M/T) or Engine and ECT ECU (A/T) (3RZ-FE, 2RZ-FE) •Pre-Heating Timer (General Diesel) A/C Amplifier. Driver Side J/B. Diff. Lock ECU. Integration Relay. ABS ECU Circuit Opening Relay ADD Control Relay. O/D ECU (Israel). Center Airbag Sensor Assembly. 22 HILUX (EWD378F). ABS Decerelation Sensor.

(9) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D. [Engine Compartment] (RHD) R/B No.5. Engine Room R/B No.2 (Diesel). Engine Room R/B (Gasoline). Engine Room R/B (Diesel). R/B No.6. CLICK HERE TO VIEW CHAPTER INDEX. [Instrument Panel] (RHD). Auto Antenna Control Relay. Dim-Dip Light Relay. Center J/B (Australia) or Connector Holder (Except Australia). •Engine ECU (M/T) or Engine and ECT ECU (A/T) (3RZ-FE, 1RZ-E, 1KZ-TE) •Emission Control ECU (3RZ-F, 1RZ, Europe 2L-T, 2L) •Pre-Heating Timer (General Diesel, 5L). Driver Side J/B. Integration Relay. Passenger Side R/B (3RZ-FE, 1RZ-E, 1KZ-TE). ABS ECU. ADD Control Relay 4WD Control ECU. A/C Amplifier. Center Airbag Sensor Assembly. ABS Decerelation Sensor. 23 HILUX (EWD378F).

(10) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS ;;; ;;; ;;;: Driver Side J/B. Lower Finish Panel (See Page 22). [LHD]. 30A POWER (for Medium Current). 1 SEAT-HTR 20A ACC 15A ECU-B 7.5A. 2 ECU-IG 15A WIPER 20A IGN 10A. 4WD 20A TURN 10A GAUGE 10A. 1 2 3 4 5 6 7 8 9 10 11 12. Integration Relay. 2. 1K 1 2 3. Power Relay. 3 5 3 2 1. 1. (from Roof Wire). 3. Horn Relay. Turn Signal Flasher. 2 1. 3 2. 2 3 5. 1. 1. Defogger Relay. 1I 1. 2. (from Engine Room Main Wire) 1 2 3 4 5 6 7 8 9 10111213. 1J. 5 4 3 2 1 13 12 11 10 9 8 7 6. 2. 1. 1H. (from Engine Room Main Wire). 1 3. 1 2 5 6 7. 3 4 8 9 10. 1A. 4 3 10 9 8. 6. 5. 4. 6. (from Engine Room Main Wire). 1. 2. 2 1 7 6 5. 2 4 5. 3. (from Cowl Wire). 1C 1 2. 1 2 3 4 5 6 7 8 9 1011. 1D. 4 3 2 1 11 10 9 8 7 6 5. 2 1. 2 1 7 6 5 4 3 12 11 10 9 8. (from Cowl Wire). (from Cowl Wire) 1B. 1 2 3 4 5 6 7 8 9 10. 1E. 5 4 3 2 1 10 9 8 7 6. 3 4 3 2 1 13 12 11 10 9 8 7 6. 4 3 2 1. (from Cowl Wire) YELLOW. (from Cowl Wire) 1G 1 2 3 4 5 6 7 8 9 10111213. 1 2 3 4 5 6 7 8 9 10 11 12. 1F. 1 2 3 4. (from Cowl Wire). (from Cowl Wire). 24 HILUX (EWD378F).

(11) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D. [Driver Side J/B Inner Circuit] [LHD] 1. 1. 1I. 2. 2 1C. 30A POWER 5. 3. 2. 1. 6 1F 1 1C 3. Power Relay. 3 1K 2 1. Turn Signal Flasher. 4 1B 10 1B 8 1B 1 1B 4 1G. 7.5A ECU-B. 1 1H. 11 1B 9 1E. 2. 1I. 4 1J. Horn Relay 3 1J. 2. 5. 3. 2. 1. 8 1A 5 1B. Defogger Relay. 3 1. 10 1E 11 1D. 1 1J. 12 1B. 5 1H. 7 1B. 10A GAUGE. 2 1F 5 1E. 20A WIPER. 4 1A 7 1E. 20A 4WD 2 1B. 10A TURN. 5 1J 2 1E. 15A ECU-IG. 6 1E 8 1E 6 1B. 20A SEAT-HTR. 3 1G 3 1B 9 1B. 3 1H. 15A ACC. 1 1G 1 1D 8 1J. 6 1H. 10A IGN. 11 1J 2 1D. 6 1J 5 1D. 6 1D. Integration Relay. 7 1D. 6 1A 7 1F. 4. 11 7. 10 1J. 6. 3 1E. 8. 4 1E. 12. 1 1E. 8 1D 12 1J 2 1K 10 1D 13 1F. 1 1A. 12 1F. 5 1F 1 1K. 2 1A. 9. 9 1D. 5 1A. 4 1D. 1 1F. 3 1D. 13 1J. 3 1A. 9 1J. 4 1F 3 1F. 7 1J. 10 1E 9 1F 8 1F. 2 1J. 11 1F. 25 HILUX (EWD378F).

(12) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS ;;; ;;; ;;;: Driver Side J/B. Lower Finish Panel (See Page 23). [RHD]. 1. ACC 15A ECU-B 7.5A. 4WD 20A TURN 10A GAUGE 10A. 30A POWER (for Medium Current). 2 ECU-IG 15A WIPER 20A IGN 10A. 1 2 3 4 5 6 7 8 9 10 11 12. Integration Relay. 1. 1K. Power Relay. 3 5 3 2 1. 1 2 3. 2. (from Roof Wire). 3. Horn Relay. Turn Signal Flasher. 2 1. 3 2. 1. Defogger Relay. 3 5. 1. 2. 1I 1 2 3 4 5 6 7 8 9 10 11 12 13. 1. 1J. 5 4 3 2 1 13 12 11 10 9 8 7 6. 2. 2. (from Engine Room Main Wire). 1. (from Engine Room Main Wire). 1H 1. 1 2 5 6 7. 3 4 8 9 10. 1A. 4 3 10 9 8. 2 1 7 6 5. 6. 3. 1. 2 5. 4. 2 4 5. 6. (from Engine Room Main Wire). 3. (from Cowl Wire). 1C 1 2. 1 2 3 4 5 6 7 8 9 10 11. 1D. 2 1 4 3 11 10 9 8 7 6 5. 2 1. 2 1 7 6 5 4 3 12 11 10 9 8. (from Cowl Wire). (from Cowl Wire) 1B. 1 2 3 4 5 6 7 8 9 10. 1E. 5 4 3 2 1 10 9 8 7 6. 3 4 3 2 1 13 12 11 10 9 8 7 6. 4 3 2 1. (from Cowl Wire) YELLOW. (from Cowl Wire) 1G 1 2 3 4 5 6 7 8 9 10111213. 1 2 3 4 5 6 7 8 9 10 11 12. 1F. 1 2 3 4. (from Cowl Wire). (from Cowl Wire). 26 HILUX (EWD378F).

(13) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D. [Driver Side J/B Inner Circuit] [RHD] 1. 1. 1I. 2. 2 1C. 30A POWER 5. 3. 2. 1. 6 1F 1 1C 3. Power Relay. 3 1K 2 1. Turn Signal Flasher. 4 1B 10 1B 8 1B 1 1B 4 1G. 7.5A ECU-B 1 1H. 11 1B 9 1E. 2. 1I. 4 1J. Horn Relay 3 1J. 2. 5. 3. 2. 1. 8 1A 5 1B. Defogger Relay. 3 1. 10 1E 11 1D 12 1B. 1 1J. 7 1B. 5 1H. 10A GAUGE. 2 1F 5 1E. 20A WIPER. 4 1A 7 1E. 20A 4WD 2 1B. 10A TURN. 5 1J 2 1E. 15A ECU-IG. 6 1E 8 1E 6 1B 3 1G 3 1B 9 1B. 3 1H. 15A ACC. 1 1G 1 1D 8 1J. 6 1H. 10A IGN. 11 1J 2 1D. 6 1J 5 1D. 6 1D. Integration Relay. 7 1D. 6 1A 7 1F. 4. 11 7. 10 1J. 6. 3 1E. 8. 4 1E. 12. 1 1E 1 1A. 8 1D 12 1J 2 1K 10 1D 13 1F. 5 1F 1 1K. 2 1A. 12 1F 9. 9 1D. 5 1A. 4 1D. 1 1F. 3 1D. 13 1J. 3 1A. 9 1J. 4 1F. 7 1J. 3 1F 10 1F 9 1F. 2 1J. 8 1F 11 1F. 27 HILUX (EWD378F).

(14) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS ;;; ;;; ;;;: Center J/B. Near the Steering Column Tube (See Page 23). [RHD Australia]. 3B. 4 5 6. 3 7. 2. 5. 6. 3 7. 8. 4. 9 10. (from Cowl Wire). BLUE 1 2. 1. 8. 3A. 3. 2 1. 8 7 6 5 4. 4 3. 2 1. 10 9 8 7 6 5. DARK GRAY. (from Cowl Wire) 3C 10 9 8. 7 6. 5 4. 3 2 1. 22 21 20. 19 18 17 16 15 14. 13 12 11. 1 2 3. 4 5. 6 7. 8 9 10. 11 12 13. 14 15 16 17 18 19. 20 21 22. (from Cowl Wire) GRAY 9 8. 7 6. 5 4. 3 2 1. 20 19. 18 17 16 15 14 13. 12 11 10. 3D. 1 2 3. 4 5. 6 7. 8 9. 10 11 12. 13 14 15 16 17 18. 19 20. (from Cowl Wire). 10 9 8 22 21 20. 7 6. 5 4. 19 18 17 16 15 14. 3 2 1. 3E. 1. 2. 3. 11 12 13. 13 12 11. 4. 5. 6. 7. 14 15 16 17 18 19. 8. 9 10. 20 21 22. (from Cowl Wire) BLACK 9 8 20 19. 7 6. 5 4. 18 17 16 15 14 13. 3 2 1 12 11 10. 3F. 1. 2. 3. 10 11 12. 4. 5. 6. 7. 13 14 15 16 17 18. (from Cowl Wire). 28 HILUX (EWD378F). 8. 9. 19 20.

(15) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. D. [Center J/B Inner Circuit] 1 3C. 11 3C. 2 3C. 12 3C. 3 3C. 13 3C. 1 3A. 14 3C. 2 3A. 15 3C. 3 3A. 16 3C. 4 3E. 4 3C. 5 3E. 5 3C. 6 3E. 6 3C. 7 3E. 7 3C. 8 3E. 8 3C. 9 3E. 9 3C. 10 3E. 10 3C. 4 3A. 13 3D. 5 3A. 14 3D. 6 3A. 15 3D. 7 3A. 16 3D. 8 3A. 17 3D. 5 3B. 18 3D. 6 3B. 19 3D. 7 3B. 20 3D. 8 3B. 11 3E. 9 3B. 12 3E. 10 3B. 13 3E. 1 3E. 14 3E. 2 3E. 15 3E. 3 3E. 16 3E. 1 3D. 17 3E. 2 3D. 18 3E. 3 3D. 19 3E. 4 3D. 20 3E. 5 3D. 21 3E. 6 3D. 22 3E. 7 3D. 17 3C. 8 3D. 18 3C. 9 3D. 19 3C. 10 3F. 20 3C. 11 3F. 21 3C. 12 3F. 22 3C. 13 3F. 1 3F. 14 3F. 2 3F. 15 3F. 3 3F. 16 3F. 4 3F. 17 3F. 5 3F. 18 3F. 6 3F. 19 3F. 7 3F. 20 3F. 8 3F. 10 3D. 9 3F. 11 3D. 1 3B. 12 3D. 2 3B 3 3B 4 3B. 29 HILUX (EWD378F).

(16) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS 2. RHD Diesel : Engine Compartment Right (See Page 23) Except RHD Diesel : Engine Compartment Left (See Page 22, 23). : Engine Room R/B. ∗1 : 15A EFI (2RZ-FE, 3RZ-FE) 15A ECD (1KZ-TE) 20A AM2 (Diesel Except 1KZ-TE). 60A ABS Fuse (Gasoline) (for High Current) 80A ABS, GLOW (Diesel) (for High Current). 1. 2 5. 100A ALT Fuse (70A Type Alternator) 80A ALT Fuse (45A, 55A Type Alternator) (for High Currnet). 2. 1. 1. 2. STARTER Relay. 3. 30A CDS FAN Fuse (for Medium Current) HEAD (RH) 2. 10A. 1. 1. 2. 1. 50A HEATER Fuse (for Medium Current). 2. HEAD (LH) 2. 10A. 1. 1. HEATER Relay. 2. HEAD (RL) 2. 10A. 1. 1. 2. 1. 3 4 5. 2. HEAD (LL) 2. 10A. 1. HORN. TAIL 2. 10A. 1 1. 7.5A. 1 1. 30A AM2 Fuse (Gasoline, 1KZ-TE) (for Medium Current). 10A. 2. 15A. 2. 2. 7.5A. 40A AM1 Fuse (for Medium Current). 1. DEFOG. OBD. A.C 2. ALT-S 2. DOME. STA 2. 15A. 15A. 1. STOP. 1. 7.5A. 2. 1. ∗1. 2. 2. 10A. 1. 1. 1 5. 3. 5. 3. CDS FAN Relay. 2. 1 2. 2. 4. 1. 3. HEAD Relay. 3. 1. DIMMER Relay 4. 2. 2. 1 5 3. EFI Relay (Gasoline) ECD Relay (1KZ-TE). 30 HILUX (EWD378F). TAIL Relay.

(17) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D. 4. : Engine Room R/B No No.2 2. LHD Diesel : Engine Compartment Left (See Page 22) RHD Diesel : Engine Compartment Right (See Page 23). 3. 4. 1. 4. 2. ST RLY. 1. 3. 2. SUB GLW RLY. CLICK HERE TO VIEW CHAPTER INDEX 5. : R/B No.5 No 5. LHD : Front Right Fender Apron (See Page 22) RHD : Near the Brake Master Cylinder (See Page 23). 1. 2. 3. 4. ABS Motor Relay. 1. 2. 4. 5. 3. 6. ABS Solenoid Relay. 31 HILUX (EWD378F).

(18) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D RELAY LOCATIONS 6. : R/B No.6. Radiator Support RH (See Page 23). [RHD w/ Dim-Dip Light]. 2. 4. 2. 3. 1. 5 4. 1. Dim-Dip Relay No.3. 3. Dim-Dip Relay No.2. CLICK HERE TO VIEW CHAPTER INDEX 7. : Passenger Side R/B. Cowl Side Panel LH (See Page 23). [RHD 3RZ-FE, 1RZ-E, 1KZ-TE]. Circuit Opening Relay (3RZ-FE,1RZ-E) Spill Control Valve Relay (1KZ-TE). 1 5. 3. 2. 32 HILUX (EWD378F).

(19) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. D. 8. : R/B No.8. Radiator Support RH (See Page 22). [Israel]. CDS FAN NO.1 Relay. CDS FAN NO.2 Relay. 2. 2 3. 4 1. 4. 3. 5. 1. 33 HILUX (EWD378F).

(20) BACK TO MAIN INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E: ELECTRICAL WIRING ROUTING: PAGE 1 OF 4 POSITION OF PARTS IN ENGINE COMPARTMENT: 1. LHD 3RZ-FE, 2RZ-FE A TO H Pg 34 2. LHD 3RZ-FE, 2RZ-FE I TO W Pg 35 3. LHD: 3RZ-F Pg 36 4. LHD: 1RZ Pg 37 5. LHD: 2L-T Pg 38 6. LHD: 3L, 2L Pg 39 POSITION OF PARTS IN INSTRUMENT PANEL: 1. LHD A TO D Pg 40 2. LHD E TO U Pg 41 POSITION OF PARTS IN BODY: 1. LHD REGULAR CAB Pg 42 2. LHD DOUBLE CAB Pg 43 3. LHD EXTRA CAB Pg 44 POSITION OF PARTS IN ENGINE COMPARTMENT: 1. RHD 3RZ-FE A TO H Pg 46 2. RHD 3RZ-FE I TO W Pg 47 3. RHD 3RZ-F Pg 48 4. RHD 1RZ-E Pg 49 5. RHD 1RZ Pg 50 6. RHD 5L Pg 51 7. RHD 2L-T Pg 52 8. RHD 3L, 2L Pg 53 9. RHD 1KZ-TE A TO H Pg 54 10. RHD 1 KZ-TE I TO W Pg 55 POSITION OF PARTS IN INSTRUMENT PANEL: 1. RHD A TO D Pg 56 2. RHD E TO U Pg 57 POSITION OF PARTS IN BODY: 1. RHD REGULAR CAB Pg 58 2. RHD DOUBLE CAB Pg 59 3. RHD EXTRA CAB Pg 60 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 62 LOCATION OF GROUND POINTS Pg 62 1. LHD 3RZ-FE, 2RZ-FE Pg 62 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 63 CONTINUED.

(21) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E: ELECTRICAL WIRING ROUTING: PAGE 2 OF 4 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 64 LOCATION OF GROUND POINTS Pg 64: 1.LHD 3RZ-R Pg 64 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 65 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 66 LOCATION OF GROUND POINTS Pg 66: 1.LHD 1RZ Pg 66 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg67 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 68 LOCATION OF GROUND POINTS Pg 68: 1.LHD 2L-T Pg 68 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg69 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 70 LOCATION OF GROUND POINTS Pg 70: 1.LHD 3L, 2L Pg 70 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg71 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 72 LOCATION OF GROUND POINTS Pg 72: 1.LHD IA1 TO IN1 Pg 72 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg73 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 74 1.LHD II1 TO IM1 Pg 74 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg75 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 76 LOCATION OF GROUND POINTS Pg 76 1.LHD DOUBLE CAB Pg 76 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg77 CONTINUED.

(22) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E: ELECTRICAL WIRING ROUTING: PAGE 3 OF4 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 78 LOCATION OF GROUND POINTS Pg 78 1.LHD REGULAR CAB Pg 78 2.LHD EXTRA CAB Pg 78 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg79 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 80 LOCATION OF GROUND POINTS Pg 80 1.RHD 3RZ-FE Pg 80 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg81 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 82 LOCATION OF GROUND POINTS Pg 82 1.RHD 3RZ-F Pg 82 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg83 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 84 LOCATION OF GROUND POINTS Pg 84 1.RHD 1RZ-E Pg 84 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg85 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 86 LOCATION OF GROUND POINTS Pg 86 1.RHD 1RZ Pg 86 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg87 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 88 LOCATION OF GROUND POINTS Pg 88 1.RHD 5L Pg 88 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg89 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 90 LOCATION OF GROUND POINTS Pg 90 1.RHD 2L-T Pg 90 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg91 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 92 LOCATION OF GROUND POINTS Pg 92 1.RHD 3L, 2L Pg 92 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg93 CONTINUED.

(23) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E: ELECTRICAL WIRING ROUTING: PAGE 4 OF4 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 94 LOCATION OF GROUND POINTS Pg 94 1.RHD 1KZ-TE Pg 94 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg95 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 96 LOCATION OF GROUND POINTS Pg 96 1.RHD IA TO 1D 1Pg 96 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg97 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 98 1.RHD IG1 TO IM2 Pg 98 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg99 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 100 LOCATION OF GROUND POINTS Pg 100 1.RHD DOUBLE CAB Pg 100 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 101 LOCATION OF CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 102 LOCATION OF GROUND POINTS Pg 102 1.RHD REGULAR CAB Pg 102 2.RHD EXTRA CAB Pg 102 CONNECTOR JOINING WIRE HARNESS & WIRE HARNESS Pg 103.

(24) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [LHD : 3RZ-FE, 2RZ-FE] (2WD) A9. A3. D1. H7. (4WD) D2. H8. (2WD)(4WD) E1. H8. H7. B1. C1. F3 F4. B2. H4. C3. A4. A6. A5. F15. A1. H1. H3. H5. (∗2 ∗3). F7. F16. (∗6). F8. F5. (∗6). (∗5). F6. F1. (∗5). F2. A 1 A 2 A 3 A 4 A 5 A 6 A 7 A 8 A 9 A 10 A 11. H6. A/C Dual Pressure SW A/C Magnetic Clutch A/T Fluid Temp. SW ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH ADD Indicator SW Air Flow Meter Alternator Alternator. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW C 1 Camshaft Position Sensor C 3 Check Connector C 4 Crankshaft Position Sensor D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position). H2. A7. A2. C4. A8. H9. A11. A10. E 1 ECT Solenoid F 1 F 2 F 3 F 4 F 5 F 6 F 7 F 8 F 15 F 16. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH Front Turn Signal Light LH Front Turn Signal Light RH Front Airbag Sensor LH Front Airbag Sensor RH. H H H H H H H H H. Headlight Beam Level Control Actuator LH Headlight Beam Level Control Actuator RH Headlight Cleaner Motor and Washer Motor Headlight Cleaner Relay Headlight LH Headlight RH Heated Oxygen Sensor (Bank 1 Sensor 1) Heated Oxygen Sensor (Bank 1 Sensor 2) Horn. 1 2 3 4 5 6 7 8 9. 34 HILUX (EWD378F).

(25) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [LHD : 3RZ-FE, 2RZ-FE] I12. W3. N1. I13. S1. T1. V7. I15. S3. S2. ∗1 : w/o ABS ∗2 : w/ ABS ∗3 : Europe ∗4 : Except Europe ∗5 : Front Turn Signal Light and Clearance Light One Body Type ∗6 : Front Turn Signal Light and Clearance Light Separeted Type. W4 W1 (∗1) V8. O1. V5. W2. V4. N2. J2. W1 (∗2 ∗4). J1. I2. I I I I I I I. 2 3 10 11 12 13 15. Ignition Coil and Igniter No.1 Ignition Coil and Igniter No.2 Injector No.1 Injector No.2 Injector No.3 Injector No.4 ISC Valve. J 1 Junction Connector J 2 Junction Connector K 1 Knock Sensor N 1 Neutral Start SW N 2 Noise Filter. I3. I11. I10. K1. S 1 Speed Sensor (ECT) S 2 Starter S 3 Starter T 1 Throttle Position Sensor V V V V. 4 5 7 8. VSV (2WD, ADD) VSV (4WD, ADD) VSV (EGR) VSV (EVAP). W W W W. 1 2 3 4. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. O 1 Oil Pressure SW. 35 HILUX (EWD378F).

(26) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [LHD : 3RZ-F] W4. A4. W2. O1. S2. C3. D1. D2. B1. C2. V9. B2. ∗1 : Front Turn Signal Light and Clearance Light One Body Type ∗2 : Front Turn Signal Light and Clearance Light Separated Type. F4 A5. F3. W1. J1. I1. J2. A1. A6. I4. F15. F16. H5. F8. F7. (∗2). (∗2). F6. F5. (∗1). (∗1). F2. F1. H6. A 1 A 2 A 4 A 5 A 6 A 7 A 10 A 11. A7. A2. I5. S3. A11. H9. A10. F 8 Front Turn Signal Light RH F 15 Front Airbag Sensor LH F 16 Front Airbag Sensor RH. A/C Dual Pressure SW A/C Magnetic Clutch ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator. H 5 Headlight LH H 6 Headlight RH H 9 Horn. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW. I I I. C 2 Carburetor C 3 Check Connector. J 1 Junction Connector J 2 Junction Connector. D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position). O 1 Oil Pressure SW. F F F F F F F. 1 2 3 4 5 6 7. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH Front Turn Signal Light LH. 1 Igniter 4 Ignition Coil No.1 5 Ignition Coil No.2. S 2 Starter S 3 Starter V 9 VSV (Throttle Position Control) W 1 Washer Motor W 2 Water Temp. Sender W 4 Wiper Motor. 36 HILUX (EWD378F).

(27) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [LHD : 1RZ] W4. A4. A5. O1. B1. C3. V2. S3. S2. B2. F3. ∗1 : Front Turn Signal Light and Clearance Light One Body Type ∗2 : Front Turn Signal Light and Clearance Light Separated Type. C2 J1 F4. J2. W1. V9. A7. A6. F16. F15. F8. H5. (∗2) F7. F6. (∗2). (∗1). F5. F2. (∗1) F1. H6. A 1 A 2 A 4 A 5 A 6 A 7 A 10 A 11. A1. A2. I6. H9. A11. A10. H 5 Headlight LH H 6 Headlight RH H 9 Horn. A/C Dual Pressure SW A/C Magnetic Clutch ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator. I. 6 IIA. J 1 Junction Connector J 2 Junction Connector O 1 Oil Pressure SW. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW. S 2 Starter S 3 Starter. C 2 Carburetor C 3 Check Connector F 1 F 2 F 3 F 4 F 5 F 6 F 7 F 8 F 15 F 16. W2. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH Front Turn Signal Light LH Front Turn Signal Light RH Front Airbag Sensor LH Front Airbag Sensor RH. V 2 Vacuum SW V 9 VSV (Throttle Position Control) W 1 Washer Motor W 2 Water Temp. Sender W 4 Wiper Motor. 37 HILUX (EWD378F).

(28) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [LHD : 2L-T] H4. W4. A10. O1. E2. G1. C3. S2. D1. D2. B1. S3. W3. B3. V10. B2. V5. F10 ∗1 : w/ Headlight Cleaner ∗2 : w/o Headlight Cleaner F3. F4. V4. A4. F9. A5 A30 A1 W1 H3. J1 (Israel) J2 (Except Israel) A31 (∗2) W2 (∗1) V12. F16. V11. A7. F15. F8. F7. F2. F1. H2. H6 A A A A A A A A A A A. 1 2 4 5 6 7 8 10 11 30 31. A11. A2. A/C Dual Pressure SW A/C Magnetic Clutch ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH ADD Indicator SW Alternator Alternator A/C Triple Pressure SW Accelerator Pedal Position Sensor. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW C 3 C 15 C 19 C 20. Check Connector Crankshaft Position Sensor Condenser Fan Motor 1 Condenser Fan Motor 2. D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position) E 2 Engine Oil Level Warning SW F F F F F F F F F F F. 1 2 3 4 7 8 9 10 15 16 17. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Heater Fuel Sedimentary SW Front Airbag Sensor LH Front Airbag Sensor RH Fuel Control Valve. V6. A8. C19. I9. C15. V15. H9. C20. V1. F17. H5. A6. H1. G 1 Glow Plug H H H H H H H. 1 2 3 4 5 6 9. Headlight Beam Level Control Actuator LH Headlight Beam Level Control Actuator RH Headlight Cleaner Motor and Washer Motor Headlight Cleaner Relay Headlight LH Headlight RH Horn. I. 9 Injection Pump. J J. 1 Junction Connector 2 Junction Connector. K 2 Kick Down SW N 1 Neutral Start SW O 1 Oil Pressure SW O 3 O/D Solenoid S 2 Starter S 3 Starter V V V V V V V V. 1 4 5 6 10 11 12 15. W W W W. 1 2 3 4. Vacuum Sensor VSV (2WD, ADD) VSV (4WD, ADD) VSV (A/C Idle-Up) VRV (EGR) VSV (BACS) VSV (EGR) VSV (Turbo Pressure Sensor) Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 38 HILUX (EWD378F).

(29) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [LHD : 3L, 2L] F4. H4. W4. V6. O1. E2. V10. B1. D1. D2. W3. V1. S2. S3. C3. B2. B3. V5. F10. F3. V4 A4. F9. A5. J1. A1 W1 H3. J2 (∗4) F15 (∗3) H1. F16. (∗2). H2. (∗1). F8 F6. F1 (∗1). (∗6) H6. 1 2 4 5 6 7 10 11 31. A7. A11. A10. A2. G1. A/C Dual Pressure SW A/C Magnetic Clutch ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator Accelerator Pedal Position Sensor. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW C 3 Check Connector C 15 Crankshaft Position Sensor. W2. (∗5) I9. C15. H9. F17. 1 2 3 4 5 6 9. A6. Headlight Beam Level Control Actuator LH Headlight Beam Level Control Actuator RH Headlight Cleaner Motor and Washer Motor Headlight Cleaner Relay Headlight LH Headlight RH Horn. I. 9 Injection Pump. J J. 1 Junction Connector 2 Junction Connector. O 1 Oil Pressure SW. E 2 Engine Oil Level Warning SW. V V V V V. 1 4 5 6 10. W W W W. 1 2 3 4. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Heater Fuel Sedimentary SW Front Airbag Sensor LH Front Airbag Sensor RH Fuel Control Valve. A31. H H H H H H H. S 2 Starter S 3 Starter. 1 2 3 4 5 6 7 8 9 10 15 16 17. W2. H5 ∗1 : Front Turn Signal Light and Clearance Light One Body Type ∗2 : Front Turn Signal Light and Clearance Light Separated Type ∗3 : w/ Headlight Cleaner ∗4 : w/o Headlight Cleaner ∗5 : Europe ∗6 : General. G 1 Glow Plug. D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position). F F F F F F F F F F F F F. F5. (∗2). F2. A A A A A A A A A. F7. Vacuum Sensor VSV (2WD, ADD) VSV (4WD, ADD) VSV (A/C Idle-Up) VRV (EGR) Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 39 HILUX (EWD378F).

(30) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Instrument Panel. [LHD] C14. C11. D7. D8. D9. D26. A25. C8. B6. A14. A16. A24. A13. ∗1 : 2-Door. D4 C10. B4. C9. B5. C12. A15. D5. A18. C7. D12 (∗1). D11 (∗1). A19. A20. C13. A 13 A 14 A 15 A 16 A 17 A 18 A 19 A 20 A 24 A 25 A 26. D10. D3. A/C Amplifier A/C SW A/C Thermistor A/C Volume SW ABS Deceleration Sensor ABS ECU ABS ECU ADD Control Relay Airbag Squib (Front Passenger's Airbag Assembly) Airbag Squib (Steering Wheel Pad) Ashtray Illumination. B 4 Blower Motor B 5 Blower Resistor B 6 Blower SW. A17. C16. C17. C18. C5. C6. A26. C 5 C 6 C 7 C 8 C 9 C10 C 11 C12 C13 C14 C16 C17 C18. Cigarette Lighter Cigarette Lighter Illumination Circuit Opening Relay Clock Combination Meter Combination Meter Combination Meter Combination SW Combination SW Combination SW Center Airbag Sensor Assembly Center Airbag Sensor Assembly Center Airbag Sensor Assembly. D 3 D 4 D 5 D 7 D 8 D 9 D10 D 11 D12 D26. Daytime Running Light Relay Diff. Lock ECU Diff. Lock SW Diode (Door Courtesy) Diode (Glow Plug) Diode (Idle-Up) DLC3 Door Courtesy SW Front LH Door Courtesy SW Front RH Diode (O/D). 40 HILUX (EWD378F).

(31) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Instrument Panel. [LHD] J21. J14. J15. J12. J13. J10. J11. J18. J8. J9. P2. H10. J19 J21 S4. J22. H11. J24. R3. J20. J7. J23. J4. E6. J3. E5. H12. E3. I18. E4. J5. P3. J6. G2. O4. I19. E E E E. 3 4 5 6. H10 Hazard SW H 11 Headlight Beam Level Control SW H12 Headlight Cleaner SW 16 17 18 19. J 3 J 4 J 5 J 6 J 7 J 8 J 9 J 10 J 10 J 11 J 12 J 13. T7. I17. Emission Control ECU Engine ECU (M/T) or Engine and ECT ECU (A/T) Engine ECU (M/T) or Engine and ECT ECU (A/T) Engine ECU (M/T) or Engine and ECT ECU (A/T). G 2 Glove Box Light. I I I I. J16. I16. U1. R4. J 14 J 15 J 16 J 18 J 19 J 20 J 21 J 22 J 23 J 24. T8. R1. R2. Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector. Ignition Key Cylinder Light Ignition SW Integration Relay Integration Relay. O 4 O/D ECU. Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector. R R R R. P 2 Parking Brake SW P 2 Pre-Heating Timer 1 2 3 4. Radio and Player Radio and Player Rear Fog Light SW Rear Window Defogger SW. S 4 Stop Light SW T 7 Transponder Key Amplifier T 8 Transponder Key Computer U 1 Unlock Warning SW. 41 HILUX (EWD378F).

(32) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING Position of Parts in Body. [LHD : Regular Cab] (∗1). (∗2). R12. R12. (∗1) D17. P10. I20. D23. R13. (∗2) P6. R13. P11. D19. ∗1 : w/ Vent Window ∗2 : w/o Vent Window. R14 P9. P15. D22. F12. D16. A29. B7. F13. D18. R7. P14. R15. R8. A28. D13. R6. R9. L1. L2. A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH. L 1 License Plate Light LH L 2 License Plate Light RH. B 7 Buckle SW. P 6 P 9 P 10 P 11 P 14 P 15. Power Window Control SW Front RH Power Window Master SW Power Window Motor Front LH Power Window Motor Front RH Pretensioner LH Pretensioner RH. R 6 R 7 R 8 R 9 R12 R13 R14 R15. Rear Combination Light LH Rear Combination Light RH Rear Diff. Lock Motor Rear Fog Light Remote Control Mirror LH Remote Control Mirror RH Remote Control Mirror SW Reverse Warning Buzzer. D13 D16 D17 D18 D19 D22 D23. Detection SW (Rear Diff. Lock) Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Speaker Front LH Door Speaker Front RH. F 12 Fuel Pump F 13 Fuel Sender I 20 Interior Light. 42 HILUX (EWD378F).

(33) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Body. [LHD : Double Cab] (∗3) ∗1 : General R12 ∗2 : Except General ∗3 : w/ Vent Window ∗4 : w/o Vent Window ∗5 : G.C.C. ∗6 : Europe. (∗4) R12. P10. S6. P4. I20. R10. P6. (∗4). (∗3). R13. R13. (∗1) P11. D19. D12. (∗2) R11. D12. P8 P13. R14. D21. D17 (∗1) D22 (∗2) P9. A29. D18. S5 D11. D15 F12. D16. B7. D15. (∗5). R7. (∗6). R15. (∗1). F13 L2 L1 D11. P14. P7. P12. D20. (∗2). A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH B 7 Buckle SW D 11 D12 D13 D14 D15 D16 D17 D18 D19 D20 D21 D22 D23. Door Courtesy SW Front LH Door Courtesy SW Front RH Detection SW (Rear Diff. Lock) Door Courtesy SW Rear LH Door Courtesy SW Rear RH Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Lock Motor Rear LH Door Lock Motor Rear RH Door Speaker Front LH Door Speaker Front RH. F 12 Fuel Pump F 13 Fuel Sender I 20 Interior Light L 1 License Plate Light LH L 2 License Plate Light RH. D14. D14. (∗1). (∗2). S7. S8. D23. P15. A28. R8. D13. R6. R9. P 4 P 6 P 7 P 8 P 9 P 10 P 11 P 12 P 13 P 14 P 15. Personal Light Power Window Control SW Front RH Power Window Control SW Rear LH Power Window Control SW Rear RH Power Window Master SW Power Window Motor Front LH Power Window Motor Front RH Power Window Motor Rear LH Power Window Motor Rear RH Pretensioner LH Pretensioner RH. R 6 R 7 R 8 R 9 R10 R 11 R12 R13 R14 R15. Rear Combination Light LH Rear Combination Light RH Rear Diff. Lock Motor Rear Fog Light Rear Window Defogger Rear Window Defogger Remote Control Mirror LH Remote Control Mirror RH Remote Control Mirror SW Reverse Warning Buzzer. S S S S. Seat Heater (Driver's Seat) Seat Heater (Front Passenger's Seat) Seat Heater SW (Driver's Seat) Seat Heater SW (Front Passenger's Seat). 5 6 7 8. 43 HILUX (EWD378F).

(34) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING Position of Parts in Body. [LHD : Extra Cab] (∗1). (∗2). R12. R12. P10. S6. R10. I20. D23. (∗1). (∗2). R13. R13. P6. R11. P11. D19. P15. R17. ∗1 : w/ Vent Window ∗2 : w/o Vent Window ∗3 : G.C.C. ∗4 : Europe. R14 D17. F12. P9. F13. D22. A29. D16. R7. D18 S5 B7. R15 (∗4) (∗3). P14. R16. A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH B 7 Buckle SW D16 D17 D18 D19 D22 D23. Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Speaker Front LH Door Speaker Front RH. F 12 Fuel Pump F 13 Fuel Sender I 20 Interior Light L 1 License Plate Light LH L 2 License Plate Light RH. S7. S8. A28. R6. R9. L1. L2. P 6 P 9 P 10 P 11 P 14 P 15. Power Window Control SW Front RH Power Window Master SW Power Window Motor Front LH Power Window Motor Front RH Pretensioner LH Pretensioner RH. R 6 R 7 R 9 R10 R 11 R12 R13 R14 R15 R16 R17. Rear Combination Light LH Rear Combination Light RH Rear Fog Light Rear Window Defogger Rear Window Defogger Remote Control Mirror LH Remote Control Mirror RH Remote Control Mirror SW Reverse Warning Buzzer Rear Speaker LH Rear Speaker RH. S S S S. Seat Heater (Driver's Seat) Seat Heater (Front Passenger's Seat) Seat Heater SW (Driver's Seat) Seat Heater SW (Front Passenger's Seat). 5 6 7 8. 44 HILUX (EWD378F).

(35) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [RHD : 3RZ-FE] C1. A3. D1. D2. (∗2). D1. E1. B1. ∗1 : w/ 2-4 Select SW ∗2 : w/o 2-4 Select SW. A8. (∗1). B2 F4. A12. A4. F3. A5. C3. A9. F15. F16. F7. F8. F1. F2. H6. A 3 A 4 A 5 A 6 A 7 A 8 A 9 A 10 A 11 A 12. A/T Fluid Temp. SW ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH ADD Indicator SW Air Flow Meter Alternator Alternator Auto Antenna Motor. A7. C4. H9. A11. A10. A6. H5. D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position) E 1 ECT Solenoid. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW. F 1 F 2 F 3 F 4 F 7 F 8 F 15 F 16. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Front Airbag Sensor LH Front Airbag Sensor RH. C 1 Camshaft Position Sensor C 3 Check Connector C 4 Crankshaft Position Sensor. H 5 Headlight LH H 6 Headlight RH H 9 Horn. 46 HILUX (EWD378F).

(36) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [RHD : 3RZ-FE] I12. W3. I13. T1. N1. S1. T3. I15. S3. S2. W4. I11. V8. O1. V5. V3. V4. K1. J2. W2. J1. W1 I3. I2. I I I I I I I. 2 3 10 11 12 13 15. Ignition Coil and Igniter No.1 Ignition Coil and Igniter No.2 Injector No.1 Injector No.2 Injector No.3 Injector No.4 ISC Valve. J 1 Junction Connector J 2 Junction Connector K 1 Knock Sensor N 1 Neutral Start SW N 2 Noise Filter O 1 Oil Pressure SW. N2. I10. S 1 Speed Sensor (ECT) S 2 Starter S 3 Starter T 1 Throttle Position Sensor T 3 2-4 Select Motor V V V V. 3 4 5 8. Variable Resistor VSV (2WD, ADD) VSV (4WD, ADD) VSV (EVAP). W W W W. 1 2 3 4. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 47 HILUX (EWD378F).

(37) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [RHD : 3RZ-F] D1. B1. S3. S2. V9. W4. B2 F3. F4. A1. I1. J2. W2. J1. I5. C2. W1. F5. F6 H6. I4. A 1 A 2 A 10 A 11. A2. A10. H5. 1 Igniter 4 Ignition Coil No.1 5 Ignition Coil No.2. O 1 Oil Pressure SW S 2 Starter S 3 Starter. D 1 Detection SW (Transfer 4WD Position) Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH. H 5 Headlight LH H 6 Headlight RH H 9 Horn. A11. J 1 Junction Connector J 2 Junction Connector. C 2 Carburetor. 3 4 5 6. H9. I I I. A/C Dual Pressure SW A/C Magnetic Clutch Alternator Alternator. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW. F F F F. O1. V 9 VSV (Throttle Position Control) W 1 Washer Motor W 2 Water Temp. Sender W 4 Wiper Motor. 48 HILUX (EWD378F).

(38) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [RHD : 1RZ-E] F4. B2. I10. I12. B1. I13. I11. T1. V1. N2. S3. S2. W4. A4 A5 F3. W2. C3. I8. J2. V3. J1. F16. I7. O1. F15. W1. A6. F8. F7. F2. H6. A 4 A 5 A 6 A 7 A 10 A 11. ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW C 3 Check Connector F 1 F 2 F 3 F 4 F 7 F 8 F 15 F 16. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Front Airbag Sensor LH Front Airbag Sensor RH. H 5 Headlight LH H 6 Headlight RH H 9 Horn. A7. W3. V6. I6. H9. A11. I I I I I I I. 6 7 8 10 11 12 13. A10. H5. F1. IIA IIA Intake Air Temp. Sensor Injector No.1 Injector No.2 Injector No.3 Injector No.4. J 1 Junction Connector J 2 Junction Connector N 2 Noise Filter O 1 Oil Pressure SW S 2 Starter S 3 Starter T 1 Throttle Position Sensor V 1 Vacuum Sensor V 3 Variable Resistor V 6 VSV (A/C Idle-Up) W W W W. 1 2 3 4. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 49 HILUX (EWD378F).

(39) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [RHD : 1RZ] B2. O1. W2. B1. V9. V2. S3. S2. W4. A1 J2 W1. J1. H6. C2. F6. A10. A2. A 1 A 2 A 10 A 11. I6. H9. I. A/C Dual Pressure SW A/C Magnetic Clutch Alternator Alternator. A11. H5. F5. 6 IIA. J 1 Junction Connector J 2 Junction Connector O 1 Oil Pressure SW. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW C 2 Carburetor. S 2 Starter S 3 Starter. F 5 Front Turn Signal Light and Clearance Light LH F 6 Front Turn Signal Light and Clearance Light RH. V 2 Vacuum SW V 9 VSV (Throttle Position Control). H 5 Headlight LH H 6 Headlight RH H 9 Horn. W 1 Washer Motor W 2 Water Temp. Sender W 4 Wiper Motor. 50 HILUX (EWD378F).

(40) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [RHD : 5L] B2. B3. O1. B1. (∗2). (∗1). D1. D1. T3. D2. W3. A8. S2. V5. W4. F10. ∗1 : w/ 2-4 Select SW ∗2 : w/o 2-4 Select SW. A4 F4 A5. A12. W1. F3. S3. V4. J2. C3. J1. I14. F16. F15. F8. F7. F2. F1. H6. A 4 A 5 A 6 A 7 A 8 A 10 A 11 A 12. A7. ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH ADD Indicator SW Alternator Alternator Auto Antenna Motor. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW C 3 Check Connector D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position) F 1 F 2 F 3 F 4 F 7 F 8 F 10 F 15 F 16. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Sedimentary SW Front Airbag Sensor LH Front Airbag Sensor RH. A11. A10. G1. I9. W2. H9. A6. H5. G 1 Glow Plug H 5 Headlight LH H 6 Headlight RH H 9 Horn I 9 Injection Pump I 14 Intake Shutter J 1 Junction Connector J 2 Junction Connector O 1 Oil Pressure SW S 2 Starter S 3 Starter T 3 2-4 Select Motor V 4 VSV (2WD, ADD) V 5 VSV (4WD, ADD) W W W W. 1 2 3 4. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 51 HILUX (EWD378F).

(41) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [RHD : 2L-T] B3. E2. I9. G1. S3. V10. W3. D1. D2. B1. S2. F17. C3. W4. F10. B2 F4 A4. F3. A5. F9. W1. A31. J2. W2. J1. V12. F16. V11. H6. F15. F8. F7. F2. A7. A 4 A 5 A 6 A 7 A 10 A 11 A 31. ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator Accelerator Pedal Position Sensor. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW C 3 Check Connector D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position) E 2 Engine Oil Level Warning SW F 1 F 2 F 3 F 4 F 7 F 8 F 9 F 10 F 15 F 16 F 17. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Heater Fuel Sedimentary SW Front Airbag Sensor LH Front Airbag Sensor RH Fuel Control Valve. A11. A10. O1. V15. F6. H9. A6. H5. F1. G 1 Glow Plug H 5 Headlight LH H 6 Headlight RH H 9 Horn I. 9 Injection Pump. J 1 Junction Connector J 2 Junction Connector O 1 Oil Pressure SW S 2 Starter S 3 Starter V 10 V 11 V 12 V 15. VRV (EGR) VSV (BACS) VSV (EGR) VSV (Turbo Pressure Sensor). W W W W. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 1 2 3 4. 52 HILUX (EWD378F).

(42) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [RHD : 3L, 2L] A4. A5. B2. B3. E2. V10. B1. D1. W3. V1. S2. C3. W4. ∗1 : Front Turn Signal Light and Clearance Light One Body Type ∗2 : Front Turn Signal Light and Clearance Light Separated Type ∗3 : Europe ∗4 : General. F4. F10. W1. F3. J1. F9. J2. S3. V6. A1 (∗3). A11 F16 F6 F8. W2 A31. (∗1) F15 (∗2). (∗1) (∗2). F2. F5 F7 F1. (∗4) H6. A 1 A 2 A 4 A 5 A 6 A 7 A 10 A 11 A 31. A7. A10. A2. O1. A/C Dual Pressure SW A/C Magnetic Clutch ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH Alternator Alternator Accelerator Pedal Position Sensor. G1. W2. H9. F 10 F 15 F 16 F 17. I9. F17. A6. H5. Fuel Sedimentary SW Front Airbag Sensor LH Front Airbag Sensor RH Fuel Control Valve. G 1 Glow Plug H 5 Headlight LH H 6 Headlight RH H 9 Horn. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW. I. 9 Injection Pump. C 3 Check Connector. J 1 Junction Connector J 2 Junction Connector. D 1 Detection SW (Transfer 4WD Position). O 1 Oil Pressure SW. E 2 Engine Oil Level Warning SW. S 2 Starter S 3 Starter. F F F F F F F F F. 1 2 3 4 5 6 7 8 9. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light and Clearance Light LH Front Turn Signal Light and Clearance Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Heater. V 1 Vacuum Sensor V 6 VSV (A/C Idle-Up) V 10 VRV (EGR) W W W W. 1 2 3 4. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 53 HILUX (EWD378F).

(43) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Engine Compartment. [RHD : 1KZ-TE] F14. B1. D2. D1. A8. G1. C15. B3. F10. B2. A12. F4. F3. A4. E2. A5. F15. F16. F7. F8. F1. F2. H6. A 4 A 5 A 6 A 7 A 8 A 10 A 11 A 12. A7. ABS Actuator ABS Actuator ABS Speed Sensor Front LH ABS Speed Sensor Front RH ADD Indicator SW Alternator Alternator Auto Antenna Motor. B 1 Back-Up Light SW B 2 Brake Fluid Level Warning SW B 3 Brake Vacuum Warning SW C 3 Check Connector C15 Crankshaft Position Sensor D 1 Detection SW (Transfer 4WD Position) D 2 Detection SW (Transfer L4 Position). A11. A10. C3. E7. H9. F 1 F 2 F 3 F 4 F 7 F 8 F 10 F 14 F 15 F 16 F 18. F18. A6. H5. Front Clearance Light LH Front Clearance Light RH Front Side Turn Signal Light LH Front Side Turn Signal Light RH Front Turn Signal Light LH Front Turn Signal Light RH Fuel Sedimentary SW First Gear Position SW Front Airbag Sensor LH Front Airbag Sensor RH Fuel Temp. Sensor. G 1 Glow Plug H 5 Headlight LH H 6 Headlight RH H 9 Horn. E 2 Engine Oil Level Warning SW E 7 Engine Speed Sensor. 54 HILUX (EWD378F).

(44) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Engine Compartment. [RHD : 1KZ-TE] V13. T3. V14. T1. V10. W3. O1. I8. W4 V5 V4 S3 S2 W1. T6. J2. W2. J1. I22 I21. S9. I 8 Intake Air Temp. Sensor I 21 Injection Pump Correction Resistor No.1 I 22 Injection Pump Correction Resistor No.2 J 1 Junction Connector J 2 Junction Connector O 1 Oil Pressure SW S 2 Starter S 3 Starter S 9 Spill Control Valve. T5. T T T T. 1 3 5 6. Throttle Position Sensor 2-4 Select Motor Timing Control Valve Turbo Pressure Sensor. V 4 V 5 V 10 V 13 V 14. VSV (2WD, ADD) VSV (4WD, ADD) VRV (EGR) VSV (Intake Constrictor Control No.1 VSV (Intake Constrictor Control No.2. W W W W. Washer Motor Water Temp. Sender Water Temp. Sensor Wiper Motor. 1 2 3 4. 55 HILUX (EWD378F).

(45) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. Position of Parts in Instrument Panel. [RHD] A13. C6. A24. A17. A27. A16. D8. D9. B6. A14. C8. D7. C9. C10. C11. C12. ∗1 : 2-Door. C13 C14 A25 (∗1). A20 D11. (∗1). B4. A 13 A 14 A 15 A 16 A 17 A 18 A 19 A 20 A 24 A 25 A 26 A 27. B5. A15. C5. A/C Amplifier A/C SW A/C Thermistor A/C Volume SW ABS Deceleration Sensor ABS ECU ABS ECU ADD Control Relay Airbag Squib (Front Passenger's Airbag Assembly) Airbag Squib (Steering Wheel Pad) Ashtray Illumination Auto Antenna Control Relay. B 4 Blower Motor B 5 Blower Resistor B 6 Blower SW. C16. C17. C18. A26. D6. D10. A19. A18. C 5 C 6 C 8 C 9 C10 C 11 C12 C13 C14 C16 C17 C18. Cigarette Lighter Cigarette Lighter Illumination Clock Combination Meter Combination Meter Combination Meter Combination SW Combination SW Combination SW Center Airbag Sensor Assembly Center Airbag Sensor Assembly Center Airbag Sensor Assembly. D 6 D 7 D 8 D 9 D10 D 11 D12. Dim-Dip Light Relay Diode (Door Courtesy) Diode (Glow Plug) Diode (Idle-Up) DLC3 Door Courtesy SW Front LH Door Courtesy SW Front RH. 56 HILUX (EWD378F). D12.

(46) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Instrument Panel. [RHD] J5. E5. E6. G2. R1. R2. P2. H10. S4. J6. J7. J14. J13 J8 J15 R3 J4. R5. J3. J9. F11. J11 J12 I19 I18. E3. E4. P3. O2. T4. T8. R4. T7. U1. J10. I17. F 11 4WD Control ECU. J 12 J 13 J 14 J 15 J 16 J 17. G 2 Glove Box Light. O 2 O/D Main SW. H10 Hazard SW. P 2 Parking Brake SW P 2 Pre-Heating Timer. E E E E. I I I I. 3 4 5 6. 16 17 18 19. J 3 J 4 J 5 J 6 J 7 J 8 J 9 J 10 J 11. Emission Control ECU Engine ECU (M/T) or Engine and ECT ECU (A/T) Engine ECU (M/T) or Engine and ECT ECU (A/T) Engine ECU (M/T) or Engine and ECT ECU (A/T). Ignition Key Cylinder Light Ignition SW Integration Relay Integration Relay Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector. R R R R R S. 1 2 3 4 5 4. I16. J16. J17. Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector Junction Connector. Radio and Player Radio and Player Rear Fog Light SW Rear Window Defogger SW Rheostat Stop Light SW. T 4 2-4 Select SW T 7 Transponder Key Amplifier T 8 Transponder Key Computer U 1 Unlock Warning SW. 57 HILUX (EWD378F).

(47) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING Position of Parts in Body. [RHD : Regular Cab] I20. D23. R14. R13. D17. P9. P11. D16. D19. P15. R12 P10 P5 D22. F12. D18. F13. P14. A29 R7 R9 L2 L1. A28. A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH D16 D17 D18 D19 D22 D23. Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Speaker Front LH Door Speaker Front RH. F 12 Fuel Pump F 13 Fuel Sender I 20 Interior Light. R6. P 5 P 9 P 10 P 11 P 14 P 15. Power Window Control SW Front LH Power Window Master SW Power Window Motor Front LH Power Window Motor Front RH Pretensioner LH Pretensioner RH. R 6 R 7 R 9 R12 R13 R14. Rear Combination Light LH Rear Combination Light RH Rear Fog Light Remote Control Mirror LH Remote Control Mirror RH Remote Control Mirror SW. L 1 License Plate Light LH L 2 License Plate Light RH. 58 HILUX (EWD378F).

(48) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Position of Parts in Body. [RHD : Double Cab] P7. R11. D23. I20. R14. R13. P11. D16. D19. D12. ∗1 : General ∗2 : Except General ∗3 : w/ Power Window ∗4 : w/o Power Window. R10. (∗1). P8 R12. P13. P10. D21 (∗1). P5 D22. F13. D18 D11 D11. D15. A29 (∗1) R7 (∗2) R9. P14. R15. (∗2) D24. P12. D20. (∗1). D14. D14. (∗4). (∗3). D17. P9. (∗2) D12. (∗2) A28. P15. D25. D15. R6. F12. L1. L2. A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH. L 1 License Plate Light LH L 2 License Plate Light RH. D 11 D12 D14 D15 D16 D17 D18 D19 D20 D21 D22 D23 D24 D25. P 5 P 7 P 8 P 9 P 10 P 11 P 12 P 13 P 14 P 15. Power Window Control SW Front LH Power Window Control SW Rear LH Power Window Control SW Rear RH Power Window Master SW Power Window Motor Front LH Power Window Motor Front RH Power Window Motor Rear LH Power Window Motor Rear RH Pretensioner LH Pretensioner RH. R 6 R 7 R 9 R10 R 11 R12 R13 R14 R15. Rear Combination Light LH Rear Combination Light RH Rear Fog Light Rear Window Defogger Rear Window Defogger Remote Control Mirror LH Remote Control Mirror RH Remote Control Mirror SW Reverse Warning Buzzer. Door Courtesy SW Front LH Door Courtesy SW Front RH Door Courtesy SW Rear LH Door Courtesy SW Rear RH Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Lock Motor Rear LH Door Lock Motor Rear RH Door Speaker Front LH Door Speaker Front RH Door Speaker Rear LH Door Speaker Rear RH. F 12 Fuel Pump F 13 Fuel Sender I 20 Interior Light. 59 HILUX (EWD378F).

(49) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING Position of Parts in Body. [RHD : Extra Cab] R11. I20. D23. D17. D16. D19. R10. P15. D22. F12. D18. F13. P14. A29 R7. A28. A 28 ABS Speed Sensor Rear LH A 29 ABS Speed Sensor Rear RH D16 D17 D18 D19 D22 D23. Door Key Lock and Unlock SW Door Lock Control SW Door Lock Motor Front LH Door Lock Motor Front RH Door Speaker Front LH Door Speaker Front RH. F 12 Fuel Pump F 13 Fuel Sender. R6. L1. L2. I 20 Interior Light L 1 License Plate Light LH L 2 License Plate Light RH P 14 Pretensioner LH P 15 Pretensioner RH R 6 R 7 R10 R 11. Rear Combination Light LH Rear Combination Light RH Rear Window Defogger Rear Window Defogger. 60 HILUX (EWD378F).

(50) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : 3RZ-FE, 2RZ-FE]. Differential Wire. EC1. Engine Wire Cowl Wire. EA EC EB Engine Room No.2 Wire EA1. EG1. Engine Room Main Wire. ED. 62 HILUX (EWD378F). Engine No.2 Wire.

(51) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EC1. GRAY. 2 1 1. 2. EG1. GRAY. 2. 1. 1 2 3 4 5 6. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EC1. Engine No.2 Wire and Differential Wire (Near the Starter). EG1. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). GRAY. 3 2 1 6 5 4. 63 HILUX (EWD378F).

(52) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : 3RZ-F]. EE Engine Wire Cowl Wire. EA. Engine Room No.2 Wire EB. EA1 EG1. Engine Room Main Wire. 64 HILUX (EWD378F). Engine No.2 Wire.

(53) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EG1. GRAY. 2 1. 1 2 3 4 5 6. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EG1. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). 65 HILUX (EWD378F).

(54) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : 1RZ]. ED. Engine Wire Cowl Wire. EA. Engine Room No.2 Wire EB. EA1 EG1. Engine Room Main Wire. 66 HILUX (EWD378F). Engine No.2 Wire.

(55) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EG1. GRAY. 2 1. 1 2 3 4 5 6. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EG1. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). 67 HILUX (EWD378F).

(56) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : 2L-T]. EF. Engine No.4 Wire. Engine Wire. Cowl Wire EE1 EA ED1 or. EB. EI1 EC1. A/C Sub Wire Engine Room No.2 Wire. EB2 EA1 Differential Wire. EH1. Engine Room Main Wire. Engine No.2 Wire. 68 HILUX (EWD378F).

(57) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. 2 1. (Except Israel). 1 2. (Israel). 1 2 3 4 5 6. EB2. GRAY. EI1. 2 1. 1 2. ED1. 1. EE1. GRAY. 2 1. EC1. GRAY. 1. 2. 2. GRAY. 2. EH1. GRAY. 2. 1. 1. 1 2 3. DARK GRAY. 2 1 3. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB2. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). EC1. Engine No.2 Wire and Differential Wire (Near the Starter). ED1. Cowl Wire and A/C Sub Wire (Front Right Fender Apron). EE1. Engine Room Main Wire and Engine Wire (Near the Engine Room R/B). EH1. Engine Room Main Wire and Engine No.4 Wire (Near the Alternator). EI1. A/C Sub Wire and Cowl Wire (Front Right Fender Apron). 69 HILUX (EWD378F).

(58) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : 3L, 2L]. EF. Engine No.4 Wire Engine Wire Cowl Wire. EA ED1 EB. Engine Room No.2 Wire A/C Sub Wire EA1. EE1. EH1 or EF2. Engine Room Main Wire. 70 HILUX (EWD378F). Engine No.2 Wire.

(59) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 2 1. 1 2. EF2. (General). 1. ED1. GRAY. 1 2. BLACK. (Europe). 1 1 2 3. EE1. GRAY. 1. 2 1. EH1. 2. GRAY. 2. 1. DARK GRAY. 2 1 3. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). ED1. Cowl Wire and A/C Sub Wire (Front Right Fender Apron). EE1. Engine Room Main Wire and Engine Wire (Near the Engine Room R/B). EF2. Engine No.4 Wire and Engine Room Main Wire (Near the Alternator). EH1. Engine Room Main Wire and Engine No.4 Wire (Near the Alternator). 71 HILUX (EWD378F).

(60) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD]. Roof Wire. Cowl Wire. A/C Sub Wire. Engine Wire. Engine Room No.2 Wire Cowl No.3 Wire. IE1 IN1. II IA1 or IA2. IJ Front Door RH Wire. Engine Room Main Wire IG IC1 IB1. Cowl No.3 Wire. IB2 Front Door LH Wire IC2 Cowl No.3 Wire IH Cowl No.3 Wire. 72 HILUX (EWD378F). IG1.

(61) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness (Europe). IA1. GRAY. (General). 1 2 5 6. IA2. GRAY. 3 4 7. 8. 4 3. 9 10. 10 9. 1 5 13. 2. 3. 6 7 8. 9 10 11. 14 15 16 17 18 19 20 22. 23 24 25. IB1. 26. 4 12. 12. 21. 21. 2. 11 10 9. 26. 25 24 23. IC2. 1. 2. 3. 4. 6. 7. 8. 9 10. 5. 13. 5. 4. 3. 2. 1. 10 9. 8. 7. 6. 1 3 8. 2 4 5 6 7 9 10 11 12. IG1. 1 1 2. IC1. GREEN. IE1. 1. 1. 7 8. 2. 7. 1 6. 5. 4. 3. 12 11 10 9. 8. YELLOW. 2 1. 1. 6 5 4 3. GRAY. 2. IN1. 2. 3 4 5 6. 2 1. 6 5. 5. 22. IB2. 7. 1. 8 7 6. 20 19 18 17 16 15 14. GREEN. 5 4 3 2 1. 1 2 3 4 5. 3. 4. 2 1 8. 1 2. 8 7. Code IA1 IA2 IB1 IB2 IC1 IC2. Joining Wire Harness and Wire Harness (Connector Location) Engine Room Main Wire and Cowl Wire (Cowl Side Panel LH) Front Door LH Wire and Cowl Wire (Left Kick Panel) Cowl Wire and Cowl No.3 No 3 Wire (Left Kick Panel). IE1. Cowl Wire and Roof Wire (Instrument Panel Reinforcement Left). IG1. Cowl Wire and A/C Sub Wire (Near the A/C Unit). IN1. Engine Room Main Wire and Cowl Wire (Under the Combination Meter). 73 HILUX (EWD378F).

(62) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness. [LHD]. Roof Wire. Cowl Wire. A/C Sub Wire. Engine Wire. IJ3. IK1. Engine Room No.2 Wire Cowl No.3 Wire IJ1 or IJ2 IJ4 or IJ5 Front Door RH Wire. Engine Room Main Wire. IL1 IL2 IM1 Cowl No.3 Wire. Front Door LH Wire Cowl No.3 Wire. Cowl No.3 Wire. 74 HILUX (EWD378F). II1.

(63) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness II1. (Gasoline). 2 1. 1 2. IJ1. (Diesel). 5 4 3 2 1. 1 2 3 4 5. IJ3. 1 2 3 4 5 6 7. (General). Code II1. IK1. 4 3. 2 1. 1 2. 5 4 3 2 1 13 12 11 10 9 8 7 6. IL1. BLUE. 2 1. 11 10 9 8 7 6 5. 1 2 3 4 5. GREEN. 5 4 3 2 1. IM1. GREEN. 1 2. 5 4 3 2 1 10 9 8 7 6. IJ4. 1 2 3 4 5 6 7 8 9 10 11 12 13. IJ5. IL2. 1 2 3 4 5 6 7. 1. 7 6 5 4 3. 1 2 3 4 5 6 7 8 9 10 11. 1 2 3 4 5 6 7 8 9 10. (Europe). 2. IJ2. 1. 1. 7 6 5 4 3. Joining Wire Harness and Wire Harness (Connector Location) Cowl Wire and Cowl No.3 Wire (Behind the Ashtray). IJ1 IJ2 IJ3. Engine Wire and Cowl Wire (Behind the Glove Box). IJ4 IJ5 IK1 IL1 IL2 IM1. Engine Room No.2 Wire and Cowl No.3 Wire (Behind the Glove Box) Front Door RH Wire and Cowl Wire (Right Kick Panel) Cowl Wire and Cowl No.3 Wire (Cowl Side Panel RH). 75 HILUX (EWD378F).

(64) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : Double Cab]. BC1. Roof Wire. Cowl No.3 Wire. BB1. Front Door RH Wire. Front Door RH Wire. BK. Rear Window No.2 Wire. BH1 Rear Door RH Wire. Front Door LH Wire. Cowl Wire BA1. BD1 Cowl No.3 Wire. Front Door LH Wire. BE1 Cowl No.3 Wire. BG1. BF1. Rear Door LH Wire. Cowl Wire. BC2. Differential Wire. 76 HILUX (EWD378F). Speed Sensor Wire. Frame Wire.

(65) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness BA1. 1 2 3. BB1. 3 2 1. 1 2 3. 3 2 1. BC1. 1 2 3 4 5 6 7 8 9 10 11 12 13. BC2. BD1. 1 2 3 4 5 6. 1 2 3 4 5. 5 4 3 2 1 13 12 11 10 9 8 7 6. BE1. 2 1. 1 2 3 4. 4 3. 5 6 7 8. BF1. 4. 3. 2. 1. 8. 7. 6. 5. 2 1 6 5 4 3 8 7. 1 2 3 4 5 6 7 8. 2 1 6 5 4 3 8 7. Joining Wire Harness and Wire Harness (Connector Location). BA1. Front Door LH Wire and Front Door LH Wire (Front LH Door Inside). BB1. Front Door RH Wire and Front Door RH Wire (Front RH Door Inside). BC2. 2 1 4 3. BH1. Code. BC1. 1 2 3 4. GRAY. 6 5. BG1. 1 2 3 4 5 6 7 8. 5 4 3 2 1. Frame Wire and Cowl Wire (Under the Front Passenger Passenger's s Seat). BD1. Frame Wire and Cowl No.3 Wire (Under the Front Passenger's Seat). BE1. Frame Wire and Differential Wire (Near the No.5 Cross Member). BF1. Frame Wire and Speed Sensor Wire (Near the No.5 Cross Member). BG1. Rear Door LH Wire and Cowl Wire (Left Center Pillar). BH1. Rear Door RH Wire and Cowl Wire (Right Center Pillar). 77 HILUX (EWD378F).

(66) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [LHD : Regular Cab] Roof Wire. BC1. Front Door RH Wire. BB1. Front Door RH Wire. Cowl No.3 Wire. BD1 Front Door LH Wire. Cowl Wire. BE1. BA1. BF1. Front Door LH Wire. Cowl Wire. [LHD : Extra Cab] Cowl No.3 Wire. BC2. Differential Wire. Speed Sensor Wire. Frame Wire. CLICK HERE TO VIEW CHAPTER INDEX Front Door RH Wire. BK. Rear Window No.2 Wire. BB1. Front Door RH Wire. Front Door LH Wire. Cowl Wire BD1 BA1 BF1 Front Door LH Wire. Cowl Wire. BC1. Speed Sensor Wire. 78 HILUX (EWD378F). Frame Wire.

(67) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness BA1. 1 2 3. BB1. 3 2 1. 1 2 3. 3 2 1. BC1. 1 2 3 4 5 6 7 8 9 10 11 12 13. BC2. BD1. 1 2 3 4 5 6. 1 2 3 4 5. 5 4 3 2 1 13 12 11 10 9 8 7 6. BE1. 2 1. 1 2 3 4. 4 3. 5 6 7 8. BF1. 4. 3. 2. 1. 8. 7. 6. 5. Joining Wire Harness and Wire Harness (Connector Location). BA1. Front Door LH Wire and Front Door LH Wire (Front LH Door Inside). BB1. Front Door RH Wire and Front Door RH Wire (Front RH Door Inside). BC2. 1 2 3 4. GRAY. 2 1 4 3. 6 5. Code. BC1. 5 4 3 2 1. Frame Wire and Cowl Wire (Under the Front Passenger Passenger's s seat). BD1. Frame Wire and Cowl No.3 Wire (Under the Front Passenger's Seat). BE1. Frame Wire and Differential Wire (Near the No.5 Cross Member). BF1. Frame Wire and Speed Sensor Wire (Near the No.5 Cross Member). 79 HILUX (EWD378F).

(68) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 3RZ-FE]. Differential Wire. ED1. Engine Wire Engine Room No.2 Wire. Cowl Wire. EA EC. EB. EA1 EB3. Engine Room Main Wire. ED. 80 HILUX (EWD378F). Engine No.2 Wire.

(69) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EB3. GRAY. 2 1. 1 2 3 4 5 6. ED1. GRAY. 3 2 1 6 5 4. 1. 2. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB3. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). ED1. Engine No.2 Wire and Differential Wire (Near the Starter). GRAY. 2. 1. 81 HILUX (EWD378F).

(70) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 3RZ-F]. Engine Wire. Cowl Wire. EE. EB. EB3. Engine Room Main Wire. 82 HILUX (EWD378F). Engine No.2 Wire.

(71) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E. Connector Joining Wire Harness and Wire Harness EB3. 1 2 3 4 5 6. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EB3. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). 83 HILUX (EWD378F).

(72) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 1RZ-E]. ED. Engine Wire Engine Room No.2 Wire. Cowl Wire. EA. EB. EA1 EB3. Engine Room Main Wire. 84 HILUX (EWD378F). Engine No.2 Wire.

(73) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EB3. GRAY. 2 1. 1 2 3 4 5 6. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB3. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). 85 HILUX (EWD378F).

(74) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 1RZ]. ED. Engine Wire. Cowl Wire. EB. EB3. Engine Room Main Wire. 86 HILUX (EWD378F). Engine No.2 Wire.

(75) CLICK HERE TO VIEW CHAPTER INDEX. EWD378F Pages From Supplement TO MODEL INDEX. E. Connector Joining Wire Harness and Wire Harness EB3. 1 2 3 4 5 6. GRAY. 3 2 1 6 5 4. Code. Joining Wire Harness and Wire Harness (Connector Location). EB3. Engine No.2 Wire and Engine Room Main Wire (Near the Engine Room R/B). 87 HILUX (EWD378F).

(76) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 5L]. EG. Differential Wire. ED1. Engine No.4 Wire. Engine Wire. Engine Room No.2 Wire. Cowl Wire. EA EF1 EF. EA1. EC1 EB2. Engine Room Main Wire. 88 HILUX (EWD378F). Engine No.2 Wire.

(77) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. EB2. GRAY. 2 1. 1 2. ED1. 1. 2. 2. EF1. GRAY. 1 1. 2. 2. EC1. GRAY. 1. 1 2. GRAY. 2 1. BLACK. 1. 1. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB2. Engine Room Main Wire and Engine Wire (Near the Engine Room R/B). EC1. Engine No.2 Wire and Cowl Wire (Near the Engine Room R/B). ED1. Engine No.2 Wire and Differential Wire (Near the Starter). EF1. Engine No.4 Wire and Engine Room Main Wire (Near the Alternator). 89 HILUX (EWD378F).

(78) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 2L-T]. EG. Engine No.4 Wire. Engine Wire. Engine Room No.2 Wire. Cowl Wire. EA EF3 EF. EA1 EB2. Engine Room Main Wire. 90 HILUX (EWD378F). Engine No.2 Wire.

(79) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 1 2. EB2. GRAY. 2 1. 1. 2. EF3. GRAY. 2. 1. 1 2 3. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB2. Engine Room Main Wire and Engine Wire (Near the Engine Room R/B). EF3. Engine Room Main Wire and Engine No.4 Wire (Near the Alternator). DARK GRAY. 2 1 3. 91 HILUX (EWD378F).

(80) CLICK HERE TO VIEW CHAPTER INDEX. E ELECTRICAL WIRING ROUTING. EWD378F Pages From Supplement TO MODEL INDEX. : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points. [RHD : 3L, 2L]. EG. Engine No.4 Wire. Engine Wire. Engine Room No.2 Wire EA. Cowl Wire. EF EE1 EF1 or EF3 EB2. EA1. A/C Sub Wire. Engine Room Main Wire. 92 HILUX (EWD378F). Engine No.2 Wire.

(81) EWD378F Pages From Supplement TO MODEL INDEX. CLICK HERE TO VIEW CHAPTER INDEX. E. Connector Joining Wire Harness and Wire Harness EA1. 2 1. 1 2. EF1. 1. EB2. GRAY. 1. EF3. BLACK. 1 1 2 3. 2. 2. EE1. GRAY. 1. 1 2. GRAY. 2 1. DARK GRAY. 2 1 3. Code. Joining Wire Harness and Wire Harness (Connector Location). EA1. Engine Room No.2 Wire and Engine Room Main Wire (Front Right Fender Apron). EB2. Engine Room Main Wire and Engine Wire (Near the Engine Room R/B). EE1. Engine Room Main Wire and A/C Sub Wire (Near the Battery). EF1. Engine No.4 Wire and Engine Room Main Wire (Near the Alternator). EF3. Engine Room Main Wire and Engine No.4 Wire (Near the Alternator). 93 HILUX (EWD378F).

No results found