GLAZING RUBBERS
AGS Commercial and Residential Products
We have pleasure in presenting to you the new Capral Glazing Rubber catalogue. This catalogue is designed to simplify the selection and ordering of Capral glazing rubbers for use in Capral proprietary window, door and glazing systems.
Glazing rubbers, wedges, channels and seals form an integral part of the engineered window, door and glazing systems designed and developed by Capral. To ensure Capral products perform as intended and to allow reliance on Capral’s technical and test report data, it is imperative that only extrusions, components and glazing rubbers supplied by Capral are used in fabrication of Capral proprietary systems.
In particular, glazing rubbers and seals are instrumental to achieving required wind, water and air infi ltration performance of Capral systems. Material composition, dimensional tolerances, UV stabilisation, hardness and surface fi nish can all signifi cantly effect the initial and long term performance of both the glazing rubber and the system.
Whilst a number of generic alternatives may be available on the market, such products are not tested or endorsed by Capral and are not subject to Capral’s warranties with respect to product
Introduction ====================================================================================2 300 Narrowline ===============================================================================3 400 Narrowline ===============================================================================4 425 Narrowline ===============================================================================5 406 St Lucia =====================================================================================6 419 Flushline ===================================================================================7 600 Narrowline ===============================================================================8 601 Narrowline ===============================================================================9 625 Narrowline =============================================================================10 200 Hinge Door=============================================================================11 275 Hinge Door=============================================================================12
Artisan Folding Door ====================================================================13
889 Sliding Door ===========================================================================14 900 Sliding Door ===========================================================================15 950 Sliding Window ======================================================================16 35 Awning Window ======================================================================17 50 Awning Window ======================================================================18 Euro Window ================================================================================19 580 / 480 Sliding Window ==============================================================20
581/ 481 Double Hung Window ====================================================21
582 Awning Window ====================================================================22
585 Sliding Door ===========================================================================23
Miscellaneous ===============================================================================24
Capral has a long and valued tradition of supplying aluminium extrusion and associated hardware into the Australian Window and Door industry. With our product expertise and strategic partnerships, Capral can offer a wide range of hardware optimised for our market leading products at competitive prices.
We are pleased to be able to present our current range of glazing rubbers to suit our Commercial products. While we have
endeavoured to make this catalogue as accurate as possible, we reserve the right to make changes to our product range at any time. If you have any questions about any of our glazing products, please contact your Account Manager to discuss in more detail.
Introduction
Glazing methods
A summary of different glazing methods are described below. The methods of glazing described in this manual are specifi cally for vertical glazing. Selection of materials for sloped glazing can be more critical and we recommend that advice be sought from the supplier of glazing materials.
The exact glazing pocket geometry and recommended system for each individual product is shown in its own Technical Data manual.
Pocketed Dry Glazed
This method is typically used on shopfronts and fl ush glazed doors. One bead per opening usually at the sill. It is neat, clean to execute and easily re-glazed. Carefully installed, this system is designed to be weatherproof at high Pascal ratings.
Rebate and Snap On Bead
This method is more versatile than above and allows more tolerance on glass cutting sizes. It has the highest performance potential.
Frame Pocket Size - 16mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400/300 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/300 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/300 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300021 M027214 Duoseal Door stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300841 M027403 Bulb Seal Small PVC 250m Roll PVC 250
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
300 Narrowline
Frame Pocket Size - 16mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
425 Narrowline
PVC = PVC
Frame Pocket Size - 35mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400/425 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/425 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/425 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400/425 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400/425 Glazing Wedge 9.5mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
Frame Pocket Size - 16-35mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300008 M027121 Captive Wedge 3mm Gap PVC 100
300009 M027122 Captive Wedge 5mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
Frame Pocket Size - 21-38mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300616 M027116 Captive Wedge 4.5mm Gap SA 100
300007 M027120 419 Captive Wedge 6.5mm Gap SA 100
300010 M027131 Captive Wedge 7.5mm Gap SA 50
315790 MSC6 Co-extruded Captive Wedge 3mm Gap SC 100
315789 MSC33 Co-extruded Captive Wedge 5mm Gap SC 100
301232 M027129 Glazing Wedge 4.5mm Gap SA 100
300006 M027119 Glazing Wedge 6.5mm Gap SA 100
300011 M027132 Glazing Wedge 7.5mm Gap SA 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027400 Bulb Seal Small PVC 250
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
419 Flushline
SA = Santoprene PVC = PVC
Frame Pocket Size - 20mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400/600 Glazing Wedge 3mm PVC 100
300013 M027142 400/600 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/600 Glazing Wedge 7mm PVC 100
300004 M027104 400/600 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400/600 Glazing Wedge 9.5mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
302444 302444 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300017 M027200 Wool Pile 6.9 x 6.25 PILE 350
Frame Pocket Size - 16mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400/601 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/601 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/601 Glazing Wedge7mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm GAP SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
601 Narrowline
Frame Pocket Size - 35mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200
315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100
300001 M027101 400/625 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/625 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/625 Glazing Wedge 7mm Gap PVC 100
300004 M027104 625/580 Glazing Wedge 8mm Gap PVC 100
300005 M027105 625/580 Glazing Wedge 9.5mm Gap PVC 100
302444 M027456 Door Stop Accoustic Seal Schlegel PVC 305
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300841 M027403 Bulb Seal Small PVC 250
300043 M027359 Expansion Joint Seal PVC 200
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
Frame Pocket Size - 16-35mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300001 M027101 400/200 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/200 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/200 Glazing Wedge 7mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300045 M027378 Wool Pile 13mm PILE 500
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
200 Hinge Door
Frame Pocket Size - 16mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300001 M027101 400/275 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400/275 Glazing Wedge 5mm Gap PVC 200
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300023 M027216 Duoseal Door Stop 7mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
302444 M027456 Door Stop Accoustic Seal SC 305
300043 M027359 Expansion Joint Seal PVC 200
300045 M027378 Wool Pile 13mm PILE 500
300017 M027206 Wool Pile 6.9 x 6.25 PILE 350
Frame Pocket Size - 16-35mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300001 M027101 400 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300004 M027104 580 Glazing Wedge 8mm Gap PVC 100
300005 M027105 580 Glazing Wedge 9.5mm Gap PVC 100
306867 SPD00701A Push In Buffer Seal 3mm PVC 250
302271 M027834 Ags Buffer Seal Black SC 250
306907 SPD00565B Push in buffer seal 4mm PVC 250
302273 M027836 Ags Kerf Seal Aq21 PVC 250
302274 M027837 Ags Kerf Seal Aq63 300
301296 M027239 PVC fi n pressure seal PVC 400
300743 M027171 136 Inset Sash Wiper Seal PVC 50
300045 M027378 Wool Pile 13mm PILE 500
301409 M027379 Wool Pile 16mm PILE 500
301865 M027377 Wool Pile 11mm PILE 600
302272 M027835 Fin-Seal Ags High 4.8 x 8.5 Black PILE 300
Artisan Folding Door
Panel Pocket Size - 12-30mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300030 M027241 889/950 Glazing Channel 5/6mm PVC 100 300034 M027255 889 Glazing Channel 6.5mm PVC 100 300038 M027266 889 Glazing Channel 8.38mm PVC 100 300039 M027268 889 Glazing Channel 10.38mm PVC 100 300824 M027461 889 Glazing Channel 18mm PVC 50 301263 M027462 889 Glazing Channel 25mm PVC 50 300018 M027207 Fin-Seal 6.9 x 5.25 PILE 400 300033 M027248 Fin-Seal 4.8 x 4.75 PILE 500
889 Sliding Door
900 Sliding Door
Panel Pocket Size - 14-30mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
306905 SPD00561B Backing Gasket 4.0mm PVC 300
306908 SPD00543A Backing Gasket 1.2mm PVC 300
308212 SPD02781A 6mm Gl. Channel 14mm Pocket PVC 100
308213 SPD02782A 8mm Gl. Channel 14mm Pocket PVC 100
308214 SPD02783A 10mm Gl. Channel 14mm Pocket PVC 100
306910 SPD00550A-3mm Co-Extruded Wedge 3.0mm SC 250
306911 SPD00550A-3.5mm Co-Extruded Wedge 3.5mm SC 200
306912 SPD00550A-4mm Co-Extruded Wedge 4.0mm SC 200
306913 SPD00550A-4.5mm Co-Extruded Wedge 4.5mm SC 200
306914 SPD00550A-5mm Co-Extruded Wedge 5.0mm SC 200
306915 SPD00550A-5.5mm Co-Extruded Wedge 5.5mm SC 150
306916 SPD00550A-6mm Co-Extruded Wedge 6.0mm SC 150
306909 SPD00550A-7mm Co-Extruded Wedge 7mm SC 120
314416 SPD02777A Co-Extruded Fin Seal SC 300
300841 M027403 Bulb Seal Small PVC 250
301866 M027430 Wool Pile 4.8 x 4.75 PILE 500
307393 PBF48600-2B Fin-Seal 4.8 x 6.0 PILE 400
Frame Pocket Size - 12-28mm
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300055 M027455 Glazing Channel 4mm PVC 100
300030 M027241 889/950 Glazing Channel 5mm PVC 100
300034 M027255 889/950 Glazing Channel 6.5mm PVC 100
300038 M027266 889/950 Glazing Channel 8.38mm PVC 100
300039 M027268 889/950 Glazing Channel 10.38mm PVC 100
310276 PV043BLACK0230 Glazing Wedge 3mm PVC 230
310278 PV044BLACK0250 Glazing Wedge 4mm PVC 250
309170 G021BLACK0500 Gasket Fixed Panel PVC 500
301408 M027213 Wool Pile 6.9 x 5.25 PILE 450
314769 PB69750-4B Wool Pile 6.9 x 7.5 PILE 300
310801 WP041 Fin-seal 6.9 x 7.5 PILE 300
Frame Pocket Size - 13-23mm. Sash Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300001 M027101 400/35 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400/35 Glazing Wedge 7mm Gap PVC 100
300004 M027104 580/35 Glazing Wedge 8mm Gap PVC 100
300005 M027105 580/35 Glazing Wedge 9.5mm Gap PVC 100
300021 M027214 Duoseal Door Stop 3mm Gap SC 100
300022 M027215 Duoseal Door Stop 5mm Gap SC 100
300032 M027247 Narrowline Door Stop PVC 100
300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300
300841 M027403 Bulb Seal Small PVC 250
300743 M027171 136 Sash Wiper Seal PVC 50
300043 M027359 Expansion Joint Seal PVC 200
35 Awning Window
Sash Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300001 M027101 400 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300019 M027211 50 Pivot Sash Seal PVC 100
300048 M027410 50 Iinner Sash Chan 5 & 6mm PVC 75
300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300
300841 M027403 Bulb Seal Small PVC 250
300043 M027359 Expansion Joint Seal PVC 200
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
306908 SPD00543A Backing Gasket 1.2mm PVC 300
306905 SPD00561B Backing Gasket 4.0mm PVC 300
306906 SPD00485 Closing Gasket 3.5mm PVC 150
308261 SPD01544A Euro Open Out Closing Gasket 3m Pk10 SC 30
307041 SPD00861A Euro Suite Dam Gasket PVC 100
306910 SPD00550A-3mm Co-Extruded Wedge 3.0mm SC 250
306911 SPD00550A-3.5mm Co-Extruded Wedge 3.5mm SC 200
306912 SPD00550A-4mm Co-Extruded Wedge 4.0mm PVC 200
306913 SPD00550A-4.5mm Co-Extruded Wedge 4.5mm PVC 200
306914 SPD00550A-5mm Co-Extruded Wedge 5.0mm PVC 200
306915 SPD00550A-5.5mm Co-Extruded Wedge 5.5mm PVC 150
306916 SPD00550A-6mm Co-Extruded Wedge 6.0mm PVC 150
Euro Window
Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300050 M027424 580 Glazing Channel 4mm PVC 200 300051 M027425 580 Glazing Channel 5mm PVC 200 300052 M027426 580 Glazing Channel 6mm PVC 200 301261 M027274 580/585 Glazing Channel 16mm PVC 100 300610 M027275 580/585 Glazing Channel 18mm PVC 100 300049 M027423 580 Glazing Wedge 3mm PVC 100 310276 PV043 Glazing Wedge 3mm PVC 230 310278 PV044 Glazing Wedge 4mm PVC 250
300003 M027103 400 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300033 M027248 Fin-seal 4.8 x 4.75 PILE 500
300027 M027231 580 Sill Drainage Seal PVC 250
300047 M027409 580 Sill Flap PVC 200
Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300026 M027229 581 Glazing Channel 3mm PVC 100
300029 M027235 581 Glazing Channel 4mm PVC 100
300031 M027246 581 Glazing Channel 5/6mm PVC 100
300003 M027103 400 Glazing Wedge 7mm Gap PVC 100
300001 M027101 400 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300033 M027248 Fin-seal 4.8 x 4.75 PILE 500
300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300
300047 M027409 580 Sill Flap PVC Roll 200m PVC 200
581/481 Double Hung Window
Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300026 M027229 581 Glazing Channel 3mm PVC 100
300029 M027235 581 Glazing Channel 4mm PVC 100
300031 M027246 581 Glazing Channel 5/6mm PVC 100
301261 M027274 580/585 Glazing Channel 16mm PVC 100
300610 M027275 580/585 Glazing Channel 18mm PVC 100
300001 M027101 400 Glazing Wedge 3mm Gap PVC 100
300013 M027142 400 Glazing Wedge 5mm Gap PVC 200
300003 M027103 400 Glazing Wedge 7mm Gap PVC 100
300004 M027104 400 Glazing Wedge 8mm Gap PVC 100
300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100
300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300
Pocket Size - Refer to Technical Manual
Material Old Material Material Description Material Type Roll Size (l/m) Profi le
300055 M027455 Glazing Channel 4mm PVC 100 300030 M027241 585/889 Glazing Channel 5/6mm PVC 100 300034 M027255 585/889 Glazing Channel 6.5mm PVC 100 300038 M027266 585/889 Glazing Channel 8.38mm PVC 100 300039 M027268 585/889 Glazing Channel 10.38mm PVC 100 301261 M027274 585 Glazing Channel 16mm PVC 100 300610 M027275 585 Glazing Channel 18mm PVC 100 300033 M027248 Fin-seal 4.8 x 4.75 PILE 500
585 Sliding Door
PVC = PVCMaterial Old Material Material Description Material Type Roll Size (l/m) Profi le
300035 M027257 Tape Single Sided 9 x 1.6 TAPE 45.7
300040 M027289 Fin-Seal 4.8 x 5 PILE 500
301295 M027209 Wool Pile 9 x 9 Grey PILE 150
indicates captive wedge
300 Narrowline - Frame Pocket Size 16mm
Glass Size (mm) New Material Old Material New Material Old Material
5 300003 M027103 300013 M027142 6 300013 M027142 300013 M027142 6 300013 M027142 315788 MSC28 8 300001 M027101 300001 M027142 8 315788 MSC28 300013 M027101 10 300001 M027101 300001 M027101 10 300001 M027101 315787 MSC34
400 Narrowline - Frame Pocket Size 16mm
Glass Size (mm) New Material Old Material New Material Old Material
5 300003 M027103 300013 M027142 6 300013 M027142 300013 M027142 6 300013 M027142 315788 MSC28 8 300001 M027101 300013 M027142 8 315788 MSC28 300001 M027101 10 300001 M027101 300001 M027101 10 300001 M027101 315787 MSC34
425 Narrowline - Frame Pocket Size 35mm
Glass Size (mm) New Material Old Material New Material Old Material
18 300004 M027104 300005 M027105 20 300003 M027103 300004 M027104 22 300004 M027104 300013 M027142 300013 M027142 315788 MSC28 24 300003 M027103 300013 M027142 300003 M027103 315788 MSC28 25 300013 M027142 300013 M027142 300004 M027104 315788 MSC28 26 300013 M027142 300013 M027142 300013 M027142 315788 MSC28 28 300001 M027101 300013 M027142 300001 M027101 315788 MSC28
Glazing Rubber Tables
indicates captive wedge
419 Flushline (Single Glazed) - Frame Pocket Size 21mm
Glass Size (mm) New Material Old Material New Material Old Material
6 300011 M027132 300011 M027132 6 300011 M027132 300010 M027131 8 300006 M027119 300006 M027119 8 300006 M027119 315790 MSC6 10 301232 M027129 300006 M027119 10 301232 M027129 315790 MSC6 12 301232 M027129 301232 M027129 12 301232 M027129 315789 MSC33
419 Flushline (Double Glazed) - Frame Pocket Size 38mm
Glass Size (mm) New Material Old Material New Material Old Material
24 300011 M027132 300006 M027132 24 300011 M027132 315790 MSC6 26 300011 M027132 301232 M027129 26 300006 M027119 315790 MSC6 28 300006 M027119 301232 M027129 28 300006 M027119 315789 MSC33
600 Narrowline - Frame Pocket Size 20mm
Glass Size (mm) New Material Old Material New Material Old Material
6 300003 M027103 300003 M027103 6 300005 M027105 315788 MSC28 8 300013 M027142 300003 M027103 8 300003 M027103 315788 MSC28 10 300013 M027142 300013 M027142 10 300003 M027103 315787 MSC34 12 300001 M027101 300013 M027142 12 300013 M027142 315787 MSC34
indicates captive wedge
625 Narrowline - Frame Pocket Size 35mm
Glass Size (mm) New Material Old Material New Material Old Material
18 300004 M027104 300005 M027105 20 300003 M027103 300004 M027104 22 300004 M027104 300013 M027142 300004 M027104 315788 MSC28 25 300003 M027103 300003 M027142 300003 M027103 315788 MSC28 300013 M027142 300013 M027142 300013 M027142 315788 MSC28 26 300013 M027142 300013 M027142 315788 MSC28 300013 M027142 28 300001 M027101 300013 M027142 300001 M027101 315788 MSC28
200 Hinged Door - Frame Pocket Size 16mm, 25mm & 35mm
Glass Size (mm) New Material Old Material New Material Old Material
6 300013 M027142 300013 M027142 8 300001 M027101 300013 M027142 10 300001 M027101 300001 M027101 12 300003 M027103 300003 M027103 15 300013 M027142 300013 M027142 20 300001 M027101 300001 M027101 22 300003 M027103 300003 M027103 24 300003 M027103 300013 M027142 25 300001 M027101 300013 M027142
Bead
6-10mm 25mm 35mmEN2258 EU6659 EU6659
EN2288 EK7556 EU6659
275 Hinged Door
Glass Size (mm) New Material Old Material New Material Old Material
6 300013 M027142 300013 M027142
8 300001 M027101 300013 M027142
10 300001 M027101 300001 M027101
Glazing Rubber Tables
indicates captive wedge
Artisan Folding Door
Glass Size (mm) New Material Old Material New Material Old Material
6 300013 M027142 300013 M027142 8 300001 M027101 300013 M027142 10 300001 M027101 300001 M027101 12 300003 M027103 300003 M027103 15 300013 M027142 300013 M027142 20 300001 M027101 300001 M027101 22 300003 M027103 300003 M027103 24 300003 M027103 300013 M027142 25 300001 M027101 300013 M027142
Bead
6-10mm 25mm 35mmEN2258 EU6659 EU6659
EN2288 EK7556 EU6659
889 Sliding Door
Glass Size (mm) New Material Old Material Pocket (mm)
5 300030 M027241 12 6 / 6.38 300034 M027255 12 8.38 300038 M027266 12 10.38 300039 M027268 12 18 300824 M027461 30 25 301263 M027462 30
900 Sliding Door: Wedge Glazed
Glass Size (mm) Bead Backing Gasket Wedge
4
EPD0222 with single glazed
306905 306916
5 306905 306914
6 306905 306912
900 Sliding Door: Channel Glazed
Glass Size (mm) New Material Old Material
6 308212 SPD02781A
8 308213 SPD02782A
35 Awning Window
Glass Size (mm) Bead Tape New Material Old Material
3
EL6337 or EL6474 Beads & Bevel Sash
8 x 5 300005 M027105 4 8 x 5 300003 M027103 5 8 x 5 300013 M027142 6 8 x 5 300001 M027101 8 EL9448 8 x 5 300003 M027103 10 8 x 5 300003 M027103 12 8 x 5 300013 M027142 14 EU8857 8 x 5 300001 M027101 16 8 x 5 300004 M027104 20 EL9447 10 x 7 300013 M027142 25 8 x 3 300001 M027101
indicates captive wedge
950 Sliding Window: Channel Glazed
Glass Size (mm) New Material Old Material
4 300055 M027455
5 300030 M027241
6 300034 M027255
8 300038 M027266
10 300039 M027268
Glass Size (mm) Tape Wedge
22 309639 310276
25 309639 310278
Glazing Rubber Tables
indicates captive wedge
50 Awning Window
Glass Size (mm) Bead Tape New Material Old Material
5 EL6574 or EL2082 10 x 6 300013 M027142 6 10 x 6 300013 M027142 8 EL6959 10 x 6 300003 M027103 10 10 x 6 300013 M027142 12 10 x 6 300001 M027101 25 EL2081 10 x 6 300013 M027142 32 EL9447 10 x 6 300005 M027105 35 10 x 6 300003 M027103 38 10 x 6 300013 M027142
EURO Window
Glass Size (mm) Bead Backing Gasket Wedge
4 EPD0028 306905 306914 5 306905 306912 6 306908 306916 6.38 306908 306915 6.76 306908 306914 8 306908 306912 8.38 306908 306911 8.76 306908 306910 9 EPD0029 306905 306913 10 306908 306916 10.38 306908 306915 10.76 306908 306914 12 306908 306912
indicates captive wedge
Glazing Rubber Tables
580/480 Sliding Window: Wedge Glazed
Glass Size (mm) Gap New Material Old Material Bead
3 9.5 300005 M027105 300247 4 8.5 300004 M027104 4 8.5 300005 M027105 5 7.5 300003 M027103 5 7.5 300004 M027104 6 6.5 300003 M027103 14 6.5 310278 PV044BLACK0250 ED7772 16 4.5 310276 PV043BLACK0230 ED7762 18 6.5 310278 PV044BLACK0250 ED7762
580/480 Sliding Window: Channel Glazed
Glass Size (mm) New Material Old Material
3 300049 M027423 4 300050 M027424 5 300051 MO27425 6 300052 M027426 16 301261 M027274 18 300610 M027275
581/481 Double Hung Window
Glass Size (mm) New Material Old Material
3 300026 M027229
4 / 5 300029 M027235
Glazing Rubber Tables
indicates captive wedge
582 Awning Window: Wedge Glazed
Glass Size (mm) New Material Old Material Bead
3 300005 M027105 EL6474 EL6337 4 300005 M027105 5 300004 M027104 6 300003 M027103 10 300045 M027104 EL9448 12 300003 M027103 14 300013 M027142 16 300003 M027103 EU8857 18 300012 M027142 22 300005 M027105 EL9447 24 300003 M027103 26 300013 M027142 28 300001 M027101
582 Awning Window: Channel Glazed
Glass Size (mm) New Material Old Material
3 300026 M027229 4 300029 M027235 5 / 6 300031 M027246 16 301261 M027274 18 300610 M027275
585 Sliding Door
DISCLAIMER: Whilst best efforts have been made to ensure the details provided in this brochure are accurate and correct at the time of printing, Capral is not responsible for any loss or damage whatsoever arising as a result of any errors contained in this brochure. Interpretation of standards or codes within this brochure are Capral’s interpretation of such codes. Responsibility for code compliance remains with the user of this brochure. In some cases product specifi cations may be varied without notice. You should not act or rely upon any information contained in this brochure without obtaining appropriate professional advice relating to your particular circumstances.
Distribution Centres
New South Wales
Building C1 1-107 Erskine Park Road
Erskine Park NSW 2759 Northern Territory 8 Mataram Street Winnellie NT 0820 Queensland (North) 303 Woolcock Street Garbutt QLD Queensland (South) 71 Ashburn Road Bundamba QLD 4304 South Australia 38 Cavan Road Dry Creek SA 5094 Tasmania 116 Grove Road Glenorchy TAS 7010 Victoria 151 Barry Road Campbellfi eld VIC 3061
Western Australia
17 Inspiration Drive Wangara WA 6065
Tel. 1300 366 517 www.capral.com.au
