Trailer-mounted or van-integrated

Spare Parts and Accessories for

PRIMAX

Falling Weight Deflectometer

Trailer-mounted or van-integrated

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 1

Catalogue: Spare Parts and Accessories for PRIMAX FWDs

© Grontmij A/S, Pavement Consultants, Kokbjerg 5, DK-6000 Kolding

This edition was first published in 2010

All rights reserved; no part of this publication may be reproduced, stored in a retrieval system, or transmitted

in any form or by any means, electronic, mechanical, photocopying,

recording, or otherwise, without the prior written permission of the Publishers.

The English version of this catalogue is the only authorised catalogue. Any other translations of this catalogue are not valid and Grontmij | Carl Bro A/S cannot be held responsible for the contents of such catalogues.

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 2

Contents

Part 1: Introduction... 3

1.1 Field of Application... 3

Part 2: Spare Parts... 4

2.1 Geophones, Spikes and Cable... 4

2.2 Electric Equipment... 6

2.3 Buffers and rubber for load plate... 7

2.4 Light... 8 2.5 Tools... 9 2.6 Oil... 10 Part 3: Accessories... 11 3.1 Marking Equipment... 11 3.2 Load Plate... 11 3.3 Measuring Equipment... 12 3.4 Calibration... 12 3.5 Powering Solutions... 13 3.6 Safety Equipment... 14 3.7 Electronic Hardware... 14 3.8 Software... 16 Part 4: Contact... 17

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 3

Part 1: Introduction

1.1 Field of application

Spare parts and accessories included in this catalogue can be applied for the PRIMAX falling weight deflectometers as well as for earlier versions (PRI2100 ……).

The spare parts list contains components which through normal tear and wear should be expected to need replacements.

The accessories, we have listed, are equipment which could enhance the performance of your FWD.

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 4

Part 2: Spare parts

2.1 Geophones, spikes and cable

Yellow plastic cover for geophone

Geophone spikes

Long metal spike for centre geophone and short metal spike for other geophones

Geophone cable

2-core cable for geophones

Extension device for geophones

Metal device for corrected positioning of outer geophone in case of sloping geophone beam

Geophone beam cable

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 5

Burndy geophone plug (male)

Pins for Burndy geophone plug (male)

Burndy geophone plug (female)

Pins for Burndy geophone plug (female)

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 6

2.2 Electric equipment

Power relay

Auxiliary relay

100A fuse

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 7

Non-contact control switch

With cable

3-pin plug

For hydraulic valve

Temperature probe

For manual measurement of temperature

2.3 Buffers and rubber for load plate

Buffers

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 8

2.4 Light

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 9

2.5 Tools

Adjustable wrench

Fork Wrench for control switches

Set of ratchet wrenches

Set of Allen keys

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 10

Triflow spray can

Petrol can

2.6 Oil

Hydraulic oil for FWD

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 11

Part 3: Accessories

3.1 Marking equipment

Spray marking equipment

Automatic spray marking equipment for marking of each measuring point

3.2 Load plate

450 mm circular solid load plate

Load plate (special 4 split version)

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 12

3.3 Measuring equipment

T-beam for measurements behind and next to loading points on concrete slabs

Geophone

Geophone complete with cover, spike, cable and plug

3.4 Calibration

Relative calibration verification equipment for checking of whether the sensors have drifted from initial settings

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 13

3.5 Powering

solutions

12/220V power inverter

For power supply to the computer and the printer in the towing vehicle

Generator unit

24V DC, 35 AMP generator mounted on trailer for vehicle independent powering

12/24V unit

Portable power unit for use with different towing vehicles or for permanent installation on the trailer FWD to be powered by the towing vehicle

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 14

3.6 Safety

equipment

Beam with flash lights

Beam to be mounted on towing vehicle

Safety signboard

The safety signboard is recommended for use in general and on roads with heavy traffic in particular. It is a flip-up LED panel with high brightness and visible from long distances.

The LED panel has diagonal arrow and cross function thanks to its innovative high-intensity, low consumption LED lights.

The signboard is controlled from a remote control, which controls all functions such as raising/lowering of the board and the direction of indicators (lamps and sign).

3.7 Electronic hardware

Video camera and monitor (black/white) to be mounted on trailer and car, for accurate location over concrete slab joints

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 15

GPS guide system

To be mounted on trailer and car, for accurate location e.g. airport runways and taxiways. The system needs a DGPS antenna for maximal accuracy!

Video colour camera

Together with the GPS guide system monitor, a camera can be connected. Shifting to camera mode, it can be used for accurate location over concrete slab joints

IR temperature transmitter

For automated transmission of pavement surface temperatures

GPS antenna and software

GPS integrated with the PRIMAX data collection software

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 16

FWD camera

Including one camera and integrated software in the FWD data collection program.

The camera takes a picture of the spot

measured by the FWD and the picture is saved together with the FWD data.

3.8 Software

Rosy design road software

Including a 3-day training course

Rosy design airport software

Spare Parts and Accessories for FWD/HWD/SHWD PRIMAX

Grontmij A/S, Pavement Consultants Page 17

Part 4: Contact

For more information please contact:

René Clemen Production Manager Phone: +45 8228 1573 Mobile: +45 2723 1573 Email:[email protected] John Kern Technician Phone: +45 8228 1574 Mobile: +45 2723 1574 Email:[email protected] Michael Henriksen Technician Phone: +45 8228 1507 Mobile: +45 2723 1507 Email:[email protected]