Work Order History Report
Asset: WL307, Including Children, Active: True AssetWL307 Loader, Wheel (IT)
W/O No Description Finished Hours
179 WL307 R&R transfilter tested ok 3/12/2009 Hours
103 CAT WL IT62G 2000hr 17/12/2009 Hours
550 CAT WL IT62G 250hr 5/01/2010 Hours
449 WL307 Test boom for creeping 16/01/2010 Hours
786 CAT WL IT62G 1000hr 7/03/2010 Hours
2619 WL307 Repair broken hydraulic fitting on lift boom 10/06/2010 Hours 2624 WL307 Replace broken fittings on cylinders 13/07/2010 Hours
2841 CAT WL IT62G 500hr 13/07/2010 Hours
3490 WL307 Fix dash (park brake switch) 13/07/2010 Hours 2520 WL307 Repair front wipers & motor 14/07/2010 Hours 6265 WL307 Replaced globe in beacon 11/09/2010 Hours
4982 CAT WL IT62G 250hr 16/09/2010 Hours
7884 WL307 Replace worn steer cylinder pins 3/10/2010 Hours 7646 WL307 Replace oil hose 3/10/2010 Hours 6916 CAT WL IT62G 250hr : Tappet cover leaking, repaired one broken
grease line, tyre pressures tested at 95 & 70 PSI, fit steeting ram pin
4/10/2010 Hours
7647 WL307 Replace hyd hose 5/10/2010 Hours 8926 CAT WL IT62G 1000hr - Service completed, 12.12.10 11/12/2010 Hours 12021 WL307 Park brakes - don't hold on slope. Inspected and tested on
various slopes, no fault found
17/01/2011 Hours
6240 WL307 Remove & replace boom quick hitch pins, repair crack in quick hitch pin bosses
30/01/2011 Hours
7392 WL307 Inspect engine warning fault - speed sensor fault 30/01/2011 Hours 10021 CAT WL IT62G 250hr : service carried out by Ben Coates
(serviceman)
6220 WL307 Replace dip stick 16/02/2011 Hours 11696 WL307 Repair door release cable locking device 18/02/2011 Hours 15185 WL307-Hook up and test tyre handling tool, R&R twist ram,
replace hoses as req`d, rewire electrical controlRemove rotating/ tilt cyclinder, dispose switch/ wiring problem, inspecting tyre handler attachment
11/03/2011 Hours
15914 WL307 Window wipers not working - loose arm 19/03/2011 Hours 12472 CAT WL IT62G 500hr : Fuel filter bowl broken, Engine oil leak
rocker cover, Reverse lights not working, Park brake not working, Front wipers not working
11/04/2011 Hours
12370 WL307 C/O Top & bottom rocker cover gaskets 12/04/2011 Hours 18734 WL307-oil leak ontop of motor 2/05/2011 Hours 16643 WL307 Repair drive line shaft 6/06/2011 Hours 17571 WL307 Brake repairs - not working correctlySee WO 16643 for job
sheet
6/06/2011 Hours
18267 CAT WL IT62G 250hr: Adjusted park brake, changed oil & fuel & hydraulic filters, Drained engine oil & refilled, greased vehicle, checked over checklist, changed out blown globes, indicator needs new assembly as its rusted out, needs new windscreen arm, changed out rocker housing & cover gasket
6/06/2011 Hours
21058 CAT WL IT62G 2000hr : Windscreen washer spray nozzle missing, service brake holding at 2500rpm, oil leak FRHS behind alternator, steering cylinders worn on both sides, cap clamp bolts were retorqued, LHR tyre keeps going flat
29/07/2011 Hours
25344 WL307 - Repair Oil leak from filter housing and fuel leak from fuel charge pump. Clean out battery box.
5/08/2011 Hours
25346 WL307 - Test Bucket crowd circuit due to report of creeping cylinders. Tests showed to be within specifications (Actual 15mm / 5mins, spec 18mm / 5mins)
5/08/2011 Hours
25337 WL307 Carry out vehicle safety audit inspection (also see work order 25352)
5/08/2011 Hours
25352 WL307 Exact Mining Inspection - Vehicle Safety Audit Checklist (also see work order 25337)
5/08/2011 Hours
21562 WL307 Oil pressure and secondary speed sensor fault - replace sensors
7/08/2011 Hours
23566 CAT WL IT62G 250hr : front wiper on order, A/C not working, radiator core leaking, oil leak on LHS of engine, slight movement in bucket pins/bushes, tyre handler leaks, movement in bucket tilt cylinders + steering cylinders
22/08/2011 Hours
25940 CAT WL IT62G 500hr : wiper/squirter U/S, no coolant in cooling system - is water, fan, A/C and alternator belts need replacing, oil leak on RHS of engine + radiator leak, bucket was repaired, internal blade wear worn, major movement in steer cyls
3/10/2011 Hours
30391 WL307 Replace engine fan belt at next service. 9/11/2011 Hours 32483 CAT WL IT62G 250hr : window washer NW - waiting on parts, no
front wiper, lever to raise/lower seat broken off, fire exting. out of date, outer cab air filter not supplied, radiator leaking, cooling system topped up with water, fan belt replaced, engine has leaks, tyre pressures adjusted, LHSR strut has slow leak
9/11/2011 Hours
33681 WL307 Inspection/defects 9/11/2011 Hours 17569 WL307 Replace front wiper motor & wiper arm 4/03/2012 Hours 44114 WL307 Tyre flat, Poss 3 tyre continuly going down over time
inspect and repair
18/03/2012 Hours
43955 CAT WL IT62G 1000hr: A/C not very cold, no engine oil filters in stock, not fuel/water seperator filters in stock, leak found at shaft on front diff, movement found in frame connect pins and bushes, artic pins and bearings, steering cylinders and chrome pins. POS 3 has slow leak and POS 3 valve cap missing. Articulation pin movement checks all ok. Completed at Ginkgo by Lee Munro and John Oxman
26/03/2012 Hours
33572 WL307 Replace engine oil cooler gasket + orings - repair leaking oil filter housing
28/03/2012 Hours
44698 WL307 Rectify coolant leak LHS of engine 28/03/2012 Hours 29580 WL307 Carry out repairs to the rear grill from bonnet being lifted
with the tow pin in place
3/04/2012 Hours
38972 WL307 Diesel in cooling system - number 5 & 6 injector sleeves U/S
3/04/2012 Hours
25345 WL307 Radiator leak repair. Replace Hydraulic hose behind RH side tank.
10/04/2012 Hours
33575 WL307 Replace missing A/C temp control knob 10/04/2012 Hours 46185 WL307 Park brake, Inspect fault and repair as required , will not
apply
10/04/2012 Hours
33574 WL307 Replace engine oil drain valve 11/04/2012 Hours 47466 WL307 Install new E-stop due to corroded broken wires. Starting
fault; Inspect and diagnose hard starting carry out repairs as required.
47237 WL307 Tyres: Repair POS 3 tyre continualy going flat , need to strip and fit tube into tyre.
31/05/2012 Hours
54371 WL307 Bonnet actuator motor U/S inspect and repair as required 21/06/2012 Hours
53986 WL307 Replace front LHS window - outsource to G.T onsite windscreens. Quote no 181
15/07/2012 Hours
33441 WL307 C/O park brake hose, Blown hose made up temporary hose until new one arrives
16/07/2012 Hours
56978 WL307 Defect repairs, Manufacture new plate for battery box, replace cartridge in up/down tilt lever control, remove seized bolts from hydraulic tank.
16/07/2012 Hours
47468 WL307 Engine oil leak; carry out repairs as required and ordered parts if needed. Lose bolt found and leaking o-ring on hyd pump line. Degrease and pressure wash.
17/07/2012 Hours
56791 WL307 Heui fuel pump has stripped thread in oil supply line. Remove pump and order new one & install
17/07/2012 Hours
58039 WL307 Engine warning fault, found metal in oil and filter housing drain oil and refill , change filter and check engine oil pressure, Change out engine with new. Replace starter motor
29/07/2012 Hours
29005 WL307 A/C repairs and electrical to fuel guage - Check A/C system operation. Interior blower fan not working. Remove interior and test fan.
28/09/2012 Hours
65737 WL307-Inspection/Repairs/Prepare for site - Line bore loader quick hitch attachment, Carry out electrical / mechanical pre-inspection, renew rear w/lights, remove RH tail ligths, bracket assy, repair corrosion in harness to tail light. Renew front w/lights, horn assy, ground E level E-Stop. Remove & replace faulty front indicators, "P" clip from alternator wiring. Renew UHF radio, AM/FM radio, amber beacon assy, top work lights. Fit bushes to quick hitch and loader frame. Renew rear indicator assys. Pressure test A/C ok, vac down. Renew circuit breaker in fuse box, clean all corrosion from circuit breakers, carry out final inspection. Fit new vent to dash, new control knob to temp control, backing plate to rear light assemblies, co-axial lead plug @ rear of cab. Remove broken bolts from loader frame and fit steer cyl and torque retainer bolts. Drain coolant, repair hole in engine block , c/o air con vents, seat belt, air filters, cab filter, repair mounting block on quick hitch frame, c/o roller on accelerator pedal. Make template for the new battery cover with fire extinguisher. Cut out rust in door and make new panel. New inercooler pipe in, hook up all hyd hoses, pre-start machine, topped up hyd oil and filled up with coolent, put belly plates on. Final inspection, fit chocks. Sand blast door latch components, change out suction pipe, oil filter, modify cylinder guard find A/C fault, remove A/ lines and condensor. Replace A/C condenser & hose, fit new o'rings to fittings, pressure test system, VAC down system for 1 hour, re-fit belly guard.
68376 WL307-Engine change out(Smiths supplied under warranty) 25/10/2012 Hours 76015 WL307 Fit reverse sensor system to IT, carry out electrical light &
A/C check on machine, all OK.
8/02/2013 Hours
81558 wl307 engine oil leak at fuel pump 27/02/2013 Hours 82044 wl307 inspect defect as per to do list 14/03/2013 Hours 82567 wl307 bucket linkage pin squeeling 19/03/2013 Hours 82717 wl307 steering colum not holding 24/03/2013 Hours 82442 wl307 graese line leaking 27/03/2013 Hours
82058 CAT WL IT62G 250hr 30/03/2013 Hours
83488 wl307 front diff pinion seal leaking 6/04/2013 Hours 82083 wl307 seat adjuter knob missing 16/04/2013 Hours 88630 WL307 eng bay bonnet wont open 22/05/2013 Hours 94304 WL307 Inspect and prep for site - Pressure test system, found
front compressor seal leaking, Renew compressor vac down, charge system.Connect tyre handler & commission, found quick fittings U/S (replaced), found one solensoid wiring ripped off (repaired), some functions N/W, found plug at hitch U/S cleaned and repaired. Tested tyre handler - all functions OK.
23/07/2013 Hours
84620 CAT WL IT62G 500hr 23/07/2013 Hours
97078 WL307 r/h eng bay door damaged 16/08/2013 Hours 98636 WL307 blown hyd hose (l/h tilt cyl , rod end) 8/09/2013 Hours 97129 WL307 wiper motor ass u/s 25/09/2013 Hours
120969 CAT WL IT62G 250hr 5/07/2014 Hours
122987 WL307-engine running irratic 5/07/2014 Hours 123336 WL307-front wiper blade u/s 24/07/2014 Hours 124370 WL307-machine stopped - wont re-start 28/07/2014 Hours 125071 WL307-r/h eng access door removed due to damage 7/08/2014 Hours 130599 WL307 - Tyre Handler In-Op - Corrosion in wires, cut wires back,
terminated new plugs, made new blanking plug, tightened all hosses
130752 WL307 - Quick Hitch Hoses U/S - Removed hoses, sent to pirtek for replacement hoses, fitted new hoses
13/11/2014 Hours